Golden Technologies GL140 Batteries And Charging, To Charge the Batteries, Charging Batteries

Page 32

BATTERIES AND CHARGING

LiteRider™ Owner’s Manual

Rev.A_122810

X. CARE AND MAINTENANCE

BATTERIES AND CHARGING

Battery maintenance is the most important part of maintaining your scooter. Keeping the batteries fully charged helps to extend battery life. Use the following guidelines to help keep your batteries in optimum condition.

•For daily use, keep batteries fully charged. We recommend that you plug in the off-board charger after each use and charge 6-8 hours.

•If you are not going to use the scooter for more than a week, fully charge the batteries and then disconnect them from the scooter. See figure 14 on page 24.

To Charge the Batteries:

The charger for all LiteRider models is an off-board charger. To charge the batteries, plug the charger into the charger port on the battery pack or on the side of the console. See figures 25 and 26.

Figure 25. Charging Batteries

Figure 26. Charging Batteries

Battery Maintenance

GEL-cell or AGM and SLA deep-cycle batteries are used for operating Golden LiteRider scooters.

•These batteries are maintenance free.

•There is no danger of spillage or leakage, so these batteries are safely transportable on aircraft, buses, trains, etc.

•By following the procedures set out in this manual, you can expect extended life from your Golden LiteRider’s batteries.

31

Image 32

Contents MODELS GL110/GL140 Owner’s ManualY O U R L I F E I N M O T I O N LiteRider Owner’s Manual Rev.A122810LiteRider Models GL110/GL140 Standard Packing List 1 Owner’s Manual CONTENTS I. INTRODUCTION FEATURES AND BENEFITS Figure 1. LiteRider Features 4-wheelACCESSORIES FOR THE LITERIDER SCOOTER II. SAFETY MAXIMUM WEIGHTBEFORE GETTING ON YOUR LITERIDER GETTING ON YOUR LITERIDERDRIVING ON INCLINES LiteRider maximum recommend incline isFigure 2. Going Up an Incline DRIVING DOWN A DECLINEProcedure 1 - Under Power Procedure 2 - Emergency No Power3. Dismount your LiteRider 2. Dismount your LiteRiderRULES FOR USE AND OTHER SAFETY CONSIDERATIONS MEDICATIONRULES FOR USE AND OTHER SAFETY CONSIDERATIONS - continued III. EMI/RFI EMI/RFI AND YOUR LITERIDERFOR YOUR RECORDS IV. YOUR GOLDEN LiteRiderFigure 4. Your Golden LiteRider 3-wheel Specification Weight of Unit assembledGL-110 TiresSpecifications WarrantyStandard Seat Optional SeatSpeed Adjustment Dial Key SwitchV. OPERATION CONTROL PANELDC Battery Voltage Meter DELTA TILLER ADJUSTMENTDelta Tiller Throttle Control Lever To drive forward use either of the followingArmrest Width Adjustment Seat Height AdjustmentFigure 6. Armrest Width Adjustment Figure 7. Flip-up/Angle AdjustmentFigure 10. Drive Mode Brake Engaged FREEWHEEL MODEFigure 9. Freewheel Mode Brake Disengaged Figure 11. Key Switch Off Figure 12. Key Switch OnVI. RIDING YOUR LiteRider MOUNTINGBASIC DRIVING SteeringSteering in a Tight Spot Steering in ReverseRamps When proceeding up any ramp, curb, or incline CONTROL THROUGH TIGHT SPOTSIf you must stop your LiteRider while driving up a ramp Driving down a rampVII. DISASSEMBLY DISASSEMBLYFigure 14. Removing the Battery Pack Remove the Battery PackFigure 16. Lowered Tiller Separate the Drivetrain from the FrameFigure 17. Releasing the Drivetrain Figure 18. Lifting the FrameVIII. ASSEMBLY Figure 19. LiteRider Components 4-wheelReinstall the Drivetrain WATCH FINGER PLACEMENT! BE CAREFUL NOT TO PINCH YOUR FINGERSFigure 21. Battery Pack Installation Install the Battery PackInstall the Under-the-Seat and Tiller Baskets Install the SeatFigure 23. Installing the Seat Unlock the TillerTo Transport Your LiteRider IX. TRANSPORTING YOUR LITERIDERFigure 24. LiteRider Models GL110/140 X. CARE AND MAINTENANCE ROUTINE MAINTENANCECLEANING YOUR LiteRider Tires BodyBattery Maintenance BATTERIES AND CHARGINGTo Charge the Batteries Figure 25. Charging BatteriesIF YOUR LiteRider DOES NOT OPERATE Figure 27. Main Circuit BreakerPossible causes for the main circuit breaker to trip RemedyDIAGNOSTICS Resetting the Main Circuit BreakerBeep Codes 1 Beep 2 Beeps6 Beeps 4 Beeps5 Beeps 9 Beeps 7 Beeps8 Beeps XI. WARRANTY Consumer Limited WarrantyScooters Effective June Lifetime Limited WarrantyGolden Technologies’ Consumer Limited Warranty Scooters continuedOne-Year Limited Warranty Warranty ExclusionsXII. WARRANTY/REGISTRATION FORM Golden Technologies Product Registration FormOWNER INFORMATION PRODUCT INFORMATIONRev.A122810 Fold Here First Place Stamp Here Golden Technologies 401 Bridge St Old Forge, PA Fold Here SecondLiteRider Owner’s Manual LiteRiderOM122810 Models GL110/GL140Y O U R L I F E I N M O T I O N