Pride Mobility Jazzy 600 XL owner manual Cleaning Instructions Tire/Wheel Replacement

Page 37

V I I I . C A R E A N D M A I N T E N A N C E

WARNING! If you fail to store the unit properly, the frame can rust and the electronics can be damaged.

Cleaning Instructions

WARNING! Never hose off your power chair or place it in direct contact with water. Your power chair has a painted, ABS plastic body shroud that allows it to be easily wiped clean with a damp cloth.

WARNING! Never use any chemicals to clean a vinyl seat, as they may cause the seat to become slippery or dry out and crack. Use soapy water and dry the seat thoroughly.

Tire/Wheel Replacement

If you have pneumatic tires and you have a flat tire, you can replace the tube. If your chair is equipped with a solid tire insert, then you must replace the entire wheel assembly. Replacement tires, tubes, and wheel assemblies are readily avail- able through your authorized Pride Provider.

WARNING! To avoid possible injury, be sure that the controller’s power is turned off and the power chair is not in freewheel mode before performing this procedure.

WARNING! Completely deflate the tire before attempting repair.

Follow these easy steps for a quick and safe repair for both pneumatic and solid tires:

1.Turnoffthepowertothecontroller.

2.Set the power chair up on blocks.

3.Ifyouarechangingapneumatictire,completelydeflateitbeforeremovingthewheel.

4.Removethedrivewheelnutandwasherfromthewheelhub.Seefigure26.

5.Pullthewheelofftheaxle.

6.Remove the screws that fasten the two rim halves together. See figure 27.

7.Removetheoldtubefromthepneumatictireandreplaceitwithanewtubeorreplacetheentireassemblyifitisasolidtire.

8.Screwtogetherthetworimhalves.

9.Slide the wheel back onto the shaft. Make sure that the key is in the axle slot.

10.Reinstallthedrivewheelnutandwasherontothewheelhubandtighten.

11.Inflate thepneumatictire to 35psi(2.4bar)(ifequippedwithpneumatictires).

12.Remove the power chair from the blocks.

WASHER

DRIVE WHEEL NUT

Figure 26. Jazzy 600 XL Drive Wheel

TIRE

TUBE

SCREWS

REAR RIM HALF

FRONT RIM HALF

Figure 27. Jazzy 600 XL Drive Wheel Disassembled

Jazzy 600 XL

www.pridemobility.com

37

Image 37

Contents Exeter, PA St. Catharines, on F E T Y G U I D E L I N E S III N T E N T SN T R O D U C T I O N SafetyPURCHASER’S Agreement Information ExchangeMy authorized Pride Provider Pride Owners ClubS a F E T Y Product Safety SymbolsS a F E T Y Modifications Pre-Ride Safety CheckTire Inflation Weight LimitationsIncline Information Cornering Information Braking InformationPublic Streets and Roadways Outdoor Driving Surfaces Freewheel ModeStationary Obstacles Steps, Curbs, etc Stairs and EscalatorsDoors TransfersElevators Lift/Elevation ProductsMotor Vehicle Transport Inclement Weather PrecautionsPositioning Belts Reaching and BendingElectromagnetic and Radio Frequency Interference EMI/RFI AlcoholJazzy 600 XL I . Y O U R P O W E R C H a I RJazzy 600 XL Specifications Electrical Components Jazzy 600 XL Power BaseJazzy 600 XL Electrical Components To engage or disengage the drive motors Manual Freewheel LeversA S S E M B L Y Initial AssemblyTo install the seat Seat InstallationSeat Height and Seat Angle Adjustment Comfort AdjustmentsO M F O R T a D J U S T M E N T S To change the seat heightSeat Position Seatback Angle AdjustmentReclining Seat Armrest Angle Adjustment Armrest Width AdjustmentFoot Platform Height Adjustment Foot Platform Depth AdjustmentTo adjust the foot platform angle Foot Platform Angle AdjustmentTo clamp the quick release fastener Controller PositionElevating Leg Rests Swing-away FootrestsHeavy Duty Drop-in Leg Rests To change leg rest length a Multi-Axis Foot PlatesTo change foot plate position B To change foot plate tilt CB a T T E R I E S a N D C H a R G I N G To charge the batteries using the onboard chargerBatteries and Charging Charging the BatteriesFrequently Asked Questions FAQs Battery Break-inHow can I ensure maximum battery life? Why do my new batteries seem weak?How can I get maximum range or distance per charge? What type of batteries should I use?What about public transportation? How should I store my power chair and its batteries?What about shipping? Flight Controller I . O P E R a T I O NJoystick KeypadLock Mode Battery Condition MeterOn/Off Key To lock the Flight controllerError Codes Sleep Mode If EnabledError Code Probable Cause Possible Solution Speed KeysShould your power chair come in contact with water Care and MaintenanceTemperature I I . C a R E a N D M a I N T E N a N C EWeekly Checks Daily ChecksMonthly Checks Yearly ChecksJazzy 600 XL Drive Wheel Cleaning Instructions Tire/Wheel ReplacementTo replace the batteries Battery ReplacementBattery Installation Corrective Maintenance When to See Your Authorized Pride Provider for ServiceW a R R a N T Y Warranty Exclusions Reconditioned Units WarrantyService Checks and Warranty Service Exclusions also include components with damage caused byPride keeps a more detailed report on file at the factory Quality Control Jazzy 600 XL