Nikon service manual Control Head CM200, Item no Description

Page 31

Radio Exploded Mechanical Views and Parts Lists	2-17

8.3Control Head - CM200

1

2	3	7

9

6

4

5

Figure 2-16Control Head CM200

Table 2-3Control Head CM200 Parts List

Item no	Description	Part No

1	Control Head PCB	8488998U01
2	Lens	6189338U01

3	Keypad	7589330U01
4	Control Head Plastic	1589332U01

5	Knob Spring (part of knob - item 6)
6	Knob, Volume	3689331U02

7	Speaker	5005156Z02
8	Flat Cable (not shown)	3089305U01

9	Nameplate	5487790V03

Image 31

Contents Commercial Series Page CM200/CM300/PM400 Radios Foreword Table of Contents Transceiver Performance Testing Glossary This page Intentionally Left Blank Product Safety and RF Exposure Compliance Safety InformationThis page is Intentionally Blank Introduction Replacement Parts Ordering Radio Model Information This page Intentionally Left Blank Introduction Preventive MaintenanceCleaning Procedures ChapterSafe Handling of Cmos and Ldmos Devices Cleaning Internal Circuit Boards and ComponentsRigid Circuit Boards Repair Procedures and Techniques GeneralParts Replacement and Substitution Disassembling and Reassembling the Radio GeneralVolume Knob Removal Radio Disassembly DetailedControl Head Removal 3Flat Cable Removal 5Top Cover Removal Chassis Horizontal Top Cover RemovalPA Shield and DC Cable Removal Main Shield Removal8PA Shield and DC Cable Removal for High Power Models PA Clip and Main PCB Removal for Low Power Models10PA Clip and Main PCB Removal for High Power Models Main PCB Removal for High Power ModelsPCB Disassembly of Control Head CM20012Control Head Housing Removal CM300/PM400 Disassembly of Control Heads CM300/PM400Chassis Assembly for Low Power Models Radio AssemblyChassis Assembly for High Power Models Control Head Fitting Control Heads AssemblyOption Board Installation Radio Assembly 1-25 W Models Radio Exploded Mechanical Views and Parts ListsItem No Description Part Number Radio Assembly 25-40 W/25-45 W Models Item no Description Control Head CM200Control Head CM300/PM400 Motorola Part Description Application Service AidsTest Equipment FLO830308-0 Programming/Test Cable RKN4083Adapter Cable FKN8113 20Pin Configuration of FKN8113Table Number Title SetupService Monitor Test Set Power Supply GeneralCMP RF Test ModeTo enter test mode display radios HSSTest Name Communications Analyzer Radio Test Set Comment Test ModeDPL DtmfPL/DPL TPLSinad This page Intentionally Left Blank Description Kit Number CPS Programming/Flashing Setup with RIBCPS CPS Programming Setup with RIB with Telco Connector CPS Programming/Flashing Setup RiblessCPS Programming Setup with RIB CPS Programming Setup with RIB Accessory ConnectorInitial Test Equipment Control Settings Radio Tuning SetupService Monitor Test Set Power Supply Error Codes Power UP SELF-TESTPower UP SELF-TEST UHF AccessoriesAntennas VHFAudio Alarms and AccessoriesMounting Control StationPublic Address CablesPeripherals Data CES Wireless TechnologiesSCI Accessory Connector Pin FunctionSCI/DTMF Microphone Connector Pin FunctionModel Description Low Power Radios146-174 MHz CM200/CM300/PM400 Model Chart VHF2, 1-25 W, 146-174 MHzAAM50RNF9AA1AN 438-370 MHz CM200/CM300/PM400 Model ChartUHF2, 1-25 W, 438-470 MHz AAM50RNC9AA1AESD SpecificationsSpecification GeneralReceiver TransmitterVHF2, 25-45 W, 146-174 MHz High Power Radios136-162 MHz CM300 Model Chart VHF1, 25-45 W, 136-162 MHzAAM50RPF9AA1AN 438-470 MHz CM200/CM300/PM400 Model ChartUHF2, 25-40 W, 438-470 MHz AAM50RPC9AA1AUHF3, 25-40 W 465-495 MHz 465-495 MHz PM400 Model ChartAAM50SPF9AA3AN VHF1 VHF2 UHF2 UHF3 35 ∝V @ 12.5 kHz ∝V @ 25 kHz MIL-STD MIL StandardsTerm Definition Glossary of TermsPTT ResetOSW PLLVcobic VCOVswr This page Intentionally Left Blank Page 6802966C15