Lincoln Electric 10912, 10659 Welder Operation, Starting the Classic 300G GM 3.0L Gasoline Engine

Page 13

B-2

OPERATION

B-2

 

 

 

Air Cleaner - Heavy duty two stage dry type.

Muffler-A Muffler and stainless steel exhaust outlet elbow are standard.

Engine Hour Meter - A meter to record hours of oper- ation.

Engine Protection - The system shuts the engine down in the event of sudden low oil pressure or high coolant temperature. A warning light on the control panel will indicate such a fault. To reset the engine for restarting, turn the ignition switch off then on.

High Idle RPM (OCV) Adjustment- A potentiometer is mounted on the output rail that allows the operator to adjust the high idle engine speed between 1700 and 1800 RPM’S in 20 RPM increments. This is to allow further adjustment of the OCV. Total OCV adjustment range is about 10 Volts.

STARTING THE CLASSIC 300G GM 3.0L GASOLINE ENGINE

1.Turn the “IDLER” switch to “HIGH”.(Optional )

2.Turn the “IGNITION” switch to “ON”.

3.Press the Start button. When the engine starts run- ning, release button. If the engine fails to start in 20 seconds, wait 30 seconds and repeat the above procedure.

4.Observe the oil pressure. If no pressure shows with- in 30 seconds, stop the engine and consult the engine operating manual. To stop the engine, turn the “IGNITION” switch to “OFF”.

5.Allow the engine to run at high idle speed for sev- eral minutes to warm up. If idle control switch is left in “Auto” position, engine will run at 1600 RPM until engine coolant temperature reaches 130 F.

WARNING

Under NO conditions should ether or other starting fluids be used!

-------------------------------------------------------------------------

STOPPING THE ENGINE

Turn the “IGNITION” switch to “OFF”

At the end of each day’s welding, check the crankcase oil level, drain accumulated dirt and water from the sediment bowl under the fuel tank and refill the fuel tank to minimize moisture condensation in the tank. Also, running out of fuel tends to draw dirt into the fuel system.

When hauling the welder between job sites, close the fuel feed valve beneath the fuel tank.

If the fuel supply is cut off or runs out while the fuel pump is operating, air may be entrapped in the fuel distribution system. If this happens, bleeding of the fuel system may be necessary. Refer to the instruc- tions in the MAINTENANCE section of this manual.

REFER TO THE ENGINE

Operation and maintenance manual for additional information on the engine supplied with this welder.

WELDER OPERATION

WARNING

ELECTRIC SHOCK can kill.

Do not touch electrically live parts or electrode with skin or wet clothing.

Insulate yourself from work and ground.

FUMES & GASES can be dangerous.

• Keep your head out of the fumes.

Use ventilation or exhaust to remove fumes from breathing zone.

WELDING SPARKS can cause fire or explosion.

• Keep flammable material away.

ARC RAYS can burn.

• Wear eye, ear, and body protection.

DUTY CYCLE

The NEMA output rating of the Classic 300G is 300 amperes at 32 arc volts on a 60% duty cycle (consult Specifications in this manual for alternate ratings). Duty cycle is based on a ten minute period; thus, the welder can be loaded at rated output for six minutes out of every ten minute period.

CLASSIC 300G

Image 13
Contents NRTL/C Classic 300GCalifornia Proposition 65 Warnings SafetyElectric Shock can kill Iii Welding Sparks can cause fire or explosionSûreté Pour Soudage a L’Arc Précautions DE SûretéThank You Table of Contents Technical Specifications Classic 300G K1754-1 InstallationAuxiliary Power Height Width Depth WeightPRE-OPERATION Installation Safety PrecautionsGasoline PRE-OPERATION ServicePolarity Control and Cable Sizes FuelBattery Charging 4INSTALLATIONA-4Operation Design FeaturesGeneral Description Rated Output Duty CycleStarting the Classic 300G GM 3.0L Gasoline Engine Welder OperationStopping the Engine Refer to the EngineControl of Welding Current Auxiliary PowerIdler Control Operation Throttle Body Deicing SystemOrder K930-2 AccessoriesOrder K936-4 Order K814General Instructions MaintenanceBearings Commutator and BrushesEngine Maintenance Idler Control MaintenanceNameplates Purging AIR from Fuel System GM 3.0L EngineEngine Service HOW to USE Troubleshooting Guide TroubleshootingContact your local Lincoln Authorized Field Service Facility SymptomsRecommended Authorized Field Service FacilityCourse of Action Contact your local LincolnOpen Closed Electronic Idler Control Troubleshooting GuideAuxiliary Load Contact your local Lincoln Authorized Field Service Facility Troubleshooting Troubleshooting Classic 300G Diagrams Classic 300G Wiring Diagram for Codes 10912K2464-1 Remote Control Wiring / Connection Diagram 300G ClassicPrecaucion Warnung

IM659-B, 11135, 10659, 10912 specifications

Lincoln Electric is a prominent name in the welding and cutting industry, recognized for its commitment to innovation and high-quality products. Among its extensive product lineup, models such as Lincoln Electric 10912, 10659, 11135, and IM659-B stand out for their advanced features, reliable performance, and versatility.

The Lincoln Electric 10912 is a versatile welding machine designed primarily for MIG welding applications. It boasts a robust construction, which ensures durability and longevity even under demanding conditions. One of its main features is the easy-to-use interface, allowing both novice and experienced welders to operate it efficiently. The 10912 is equipped with a powerful 230V input and delivers a high output range, making it suitable for welding various materials, including mild steel, stainless steel, and aluminum. Its portability adds to its appeal, enabling users to transport it easily across job sites.

Model 10659 represents another excellent option, focusing on flux-cored welding. This machine is particularly advantageous for outdoor applications due to its wind-resistant features, making it ideal for construction and fabrication tasks. The Lincoln Electric 10659 offers a unique dual-groove design on its drive rolls, accommodating different wire sizes for enhanced flexibility. Its user-friendly settings and compact size ensure that it meets the needs of both hobbyists and professionals alike.

The Lincoln Electric 11135 model is engineered for heavy-duty applications, providing superior welding performance. This machine is recognized for its advanced inverter technology, which allows for a smoother and more stable arc. It also features adjustable output settings, providing users with precise control over their welding process. The 11135 is designed for industrial-grade performance, making it suitable for rigorous welding tasks across a range of industries.

Lastly, the IM659-B is well-regarded for its multi-process capabilities, allowing users to perform MIG, TIG, and stick welding in one compact unit. This model is equipped with advanced control features, including a digital display that simplifies settings adjustments. Its robust design and extensive compatibility with different welding materials make it an excellent choice for diverse applications.

In conclusion, Lincoln Electric's 10912, 10659, 11135, and IM659-B models exemplify the company's dedication to quality and innovation. Each model incorporates unique features and technologies that cater to specific welding needs, ensuring that professionals and hobbyists alike can find the perfect machine for their projects. With Lincoln Electric, users can expect reliable performance and impressive results, making it a top choice in the welding market.