Multiquip FS3SP operation manual Part Name QTY Remarks

Page 47

FS3SP CONCRETE SAW — BLADE SHAFT ASSY.

BLADE SHAFT ASSY.

NO

PART NO

PART NAME

QTY.

REMARKS

1

2621

ZERK FITTING

2

 

2

1162A

CAP, ZERK FITTING

2

 

3

15119

KEY, WOODRUFF #91, ANS1 #8061

2

 

4

6059B

KEY, /4 SQ. X 2"

1

 

5

15065

SHAFT, BLADE

1

 

6

15066

BEARING, PILLOW BLOCK 1 1/4 BORE

2

 

7

15063

FLANGE, BLADE INSIDE

2

 

8

15012

FLANGE, DRIVEN ASSY.

1

 

9

15093

NUT, 1-14-2B-LH

1

 

10

0448

WASHER, FLAT 7 / 16 SAE

4

 

11

15563

SCREW, HHC 7/16 -14 X 3/4

4

 

12

10799

V-BELTS

3VX375

4

20 HP ENGINE HONDA 14" BLADE

12

15897

V-BELTS

3VX355

4

20 HP ENGINE HONDA 20" BLADE

13

15365

PULLEY, 4/3V4.12 X 1.125 ID/3L2.75

1

20 HP ENGINE HONDA 14" BLADE

13

15366

PULLEY, 4/3V3.00 X 1.125 ID/3L2.75

1

20 HP ENGINE HONDA 20" BLADE

14

15060

BUSHING, OD SDS X 1- 1/4 X 1/4

1

 

15

15148

SPACER, 1.320D X 1.051D X 0.53

1

 

16

15092

NUT, 1-14-2B

1

 

17

1528

SCREW, SHS 1/4-20 X 5/16 HDP

2

 

18

2955

WASHER, LOCK 7/16 MED

4

 

19

25281

SPACER, 1.75 OD X 1.00 ID X .15

2

 

MQ-WHITEMAN FS3SP CONCRETE SAW — PARTS & OPERATION MANUAL — REV. #0 (07/15/02) — PAGE 47

Page 46 Page 48
Image 47
Page 46 Page 48
Contents Concrete SAW Page Heres HOW to GET Help Table of Contents UPS Ground Service at no charge for freight Parts Ordering ProceduresSeriously injured if you do not follow directions FS3SP Concrete SAW Safety Message Alert SymbolsAlways wear approved eye and hearing protection Always wear approved respiratory protectionFS3SP Concrete SAW Decals Machine Safety DecalsSpilled on a hot engine General SafetyFS3SP Concrete SAW Rules for Safe Operation Diamond Blade SafetySAW Transportation Safety Emergencies Maintenance SafetyFS3SP Concrete SAW Rules for Safe Operation Description Dimension MM FS3SP Concrete SAW DimensionsFS3SP Concrete SAW Weights FS3SP Concrete Saw Basic Components FS3SP Concrete SAW Major ComponentsNot Shown Part NameChoke FS3SP Concrete SAW Console ComponentsOperation hours saw has been in use Through the sawInitial Servicing To Change/Clean Air FilterEngine Drain Bolt Engine Oil Dip StickEngine Oil Limits Engine Oil Filler and CapFamiliarization Power PlantsFS3SP Concrete SAW General Information Water System Blade Guard AssemblyUnder Carriage System Blade Drive SystemSeason FS3SP Concrete SAW InspectionBefore Starting Engine Oil CheckAdditionally, when connecting the positive Do not overfill the batteryPoor performance and/or blade damage FS3SP Concrete SAW Inspection -BLADERotation downcuts with the turn of the shaft Operating areaDiamond Blade Placement FS3SP Concrete SAW Inspection -BLADE PlacementBelts and Covers Guards and Covers CheckB7.5 Check the following on the blade flange coverBelts and Pulleys Pull the Choke Knob up into the Open position FS3SP Concrete SAW- Initial START-UPStopping the Engine Push the Start SwitchFigure 23 to start the enginePush the console engine ON/OFF switch to the OFF position FS3SP Concrete SAW Initial START-UPFor wet sawing FS3SP Concrete SAW OperationSaw Alignment Wet Saw OperationBlade Speed Factors for sawing economyFinishing a Cut Diamond Blades and Blade SpeedBearing Lubrication Care FS3SP Concrete SAW MaintenanceGeneral Engine Care Drive Chainwill Reduce Chain Life AdjustV-Belt Alignment/Replacement PulleysComplete DriveV-Belts Replacement steps 1 through General Transmission CareRotate the engine down to provide slack in the V-Belts Blade Shaft Bearing ReplacementReplacement of the Blade Shaft Bearings Loosen the 4 3/8 HHC screws page 48, item DriveV-Belts ReplacementGeneral Cleanliness DriveV-Belt CheckPage Items Found In the Items Number Column FS3SP SAW Explanation of Code in Remarks ColumnItems Found In the Remarks Column FS3SP Concrete SAW Suggested Spare Parts Engine Troubleshooting FS3SP Concrete SAW Troubleshooting EngineSympton Possible Cause Solution FS3SP Concrete SAW Troubleshooting EngineFS3SP Concrete SAW Name Plate and Decals FS3SP Concrete SAW Name Plate and Decals FS3SP Concrete SAW Under Carriage Assy WHEEL, 5D X 2W X .625 ID #400 CAP FS3SP Concrete SAW Rear Axle Assy Rear Axle Assy FS3SP Concrete SAW Blade Shaft Assy Part Name QTY Remarks FS3SP Concrete SAW Engine Mount Assy MOUNT, Engine Assy FS3SP Concrete SAW Pointers and Covers Assy FS3SP Concrete SAW Pointers and Covers Assy FS3SP Concrete SAW Water System Assy 15076 15546Basic Platform Assy FS3SP Concrete SAW Basic Platform AssySCREW, HHC, Washer 1/4- 20 X 3/4 FS3SP Concrete SAW Blade Mist 20 -INCH Assy GUARD, Blade 20 Assy FS3SP Concrete SAW Manual Raise and Lower Assy FS3SP Concrete SAW Manual Raise and Lower Assy FS3SP Concrete SAW Plug KIT Push Assy Part Name QTY. Remarks FS3SP Concrete SAW Plug KIT Self Proppelled Assy 10024 NUT, Nyloc 1/4-20 15340 FS3SP Concrete SAW Plug KIT Self Proppelled AssyBattery BOX Assy FS3SP Concrete SAW Battery BOX Assy10024 NUT, Nylock 1/4 0471 FS3SP Concrete SAW Battery BOX Assy15203 FS3SP Concrete SAW Platform Bare Assy 15215 1503515069 15214Transmission Assy FS3SP Concrete SAW Transmission Assy FS3SP Concrete SAW Transmission Assy CABLE, Throttle 314VTT- 2- 30 1/4 SCREW, HHC, Washer 10- 32 X 5/8FS3SP Concrete SAW Engine Assy 15386 1572915104 15743Console Side FS3SP Concrete SAW Wiring DiagramFS3SP Electric Start Wiring Diagram Rocker Switches Terms and Conditions of Sale Parts Page FAX 310
Top Page Image Contents