Multiquip FS3SP operation manual MOUNT, Engine Assy

Page 49

FS3SP CONCRETE SAW — ENGINE MOUNT ASSY.

MOUNT, ENGINE ASSY.

 

 

NO.

PART NO.

PART NAME

QTY.

REMARKS

1

0166A

WASHER, LOCK, 3/8 MEDIUM

4

 

2

1007

NUT, HEX JAM 3/8 - 16

1

 

3

10136

WASHER, FLAT 3/8 SAE

6

 

4

15174

BOLT, CARRIAGE 3/8- 16 X 3

1

 

5

15680

MOUNT, ENGINE W/A

1

 

6

1665

SCREW, HHC 3/8- 16 X 2

4

 

7

25301

SCREW, HHC 3/8- 16 X 1, GRD 8

4

 

8

4001

WASHER, FLAT 3/8 PLTD STD. USS

2

 

MQ-WHITEMAN FS3SP CONCRETE SAW — PARTS & OPERATION MANUAL — REV. #0 (07/15/02) — PAGE 49

Page 48 Page 50
Image 49
Page 48 Page 50
Contents Concrete SAW Page Heres HOW to GET Help Table of Contents UPS Ground Service at no charge for freight Parts Ordering ProceduresSeriously injured if you do not follow directions FS3SP Concrete SAW Safety Message Alert SymbolsAlways wear approved eye and hearing protection Always wear approved respiratory protectionFS3SP Concrete SAW Decals Machine Safety DecalsSpilled on a hot engine General SafetySAW Transportation Safety Diamond Blade SafetyFS3SP Concrete SAW Rules for Safe Operation FS3SP Concrete SAW Rules for Safe Operation Maintenance SafetyEmergencies Description Dimension MM FS3SP Concrete SAW DimensionsFS3SP Concrete SAW Weights FS3SP Concrete Saw Basic Components FS3SP Concrete SAW Major ComponentsNot Shown Part NameOperation hours saw has been in use FS3SP Concrete SAW Console ComponentsThrough the saw ChokeInitial Servicing To Change/Clean Air FilterEngine Oil Limits Engine Oil Dip StickEngine Oil Filler and Cap Engine Drain BoltFS3SP Concrete SAW General Information Power PlantsFamiliarization Under Carriage System Blade Guard AssemblyBlade Drive System Water SystemBefore Starting FS3SP Concrete SAW InspectionEngine Oil Check SeasonAdditionally, when connecting the positive Do not overfill the batteryRotation downcuts with the turn of the shaft FS3SP Concrete SAW Inspection -BLADEOperating area Poor performance and/or blade damageDiamond Blade Placement FS3SP Concrete SAW Inspection -BLADE PlacementB7.5 Guards and Covers CheckCheck the following on the blade flange cover Belts and CoversBelts and Pulleys Pull the Choke Knob up into the Open position FS3SP Concrete SAW- Initial START-UPPush the console engine ON/OFF switch to the OFF position Push the Start SwitchFigure 23 to start the engineFS3SP Concrete SAW Initial START-UP Stopping the EngineSaw Alignment FS3SP Concrete SAW OperationWet Saw Operation For wet sawingFinishing a Cut Factors for sawing economyDiamond Blades and Blade Speed Blade SpeedGeneral Engine Care FS3SP Concrete SAW MaintenanceBearing Lubrication Care Complete DriveV-Belts Replacement steps 1 through AdjustV-Belt Alignment/Replacement PulleysGeneral Transmission Care Drive Chainwill Reduce Chain LifeReplacement of the Blade Shaft Bearings Blade Shaft Bearing ReplacementRotate the engine down to provide slack in the V-Belts General Cleanliness DriveV-Belts ReplacementDriveV-Belt Check Loosen the 4 3/8 HHC screws page 48, itemPage Items Found In the Remarks Column FS3SP SAW Explanation of Code in Remarks ColumnItems Found In the Items Number Column FS3SP Concrete SAW Suggested Spare Parts Engine Troubleshooting FS3SP Concrete SAW Troubleshooting EngineSympton Possible Cause Solution FS3SP Concrete SAW Troubleshooting EngineFS3SP Concrete SAW Name Plate and Decals FS3SP Concrete SAW Name Plate and Decals FS3SP Concrete SAW Under Carriage Assy WHEEL, 5D X 2W X .625 ID #400 CAP FS3SP Concrete SAW Rear Axle Assy Rear Axle Assy FS3SP Concrete SAW Blade Shaft Assy Part Name QTY Remarks FS3SP Concrete SAW Engine Mount Assy MOUNT, Engine Assy FS3SP Concrete SAW Pointers and Covers Assy FS3SP Concrete SAW Pointers and Covers Assy FS3SP Concrete SAW Water System Assy 15076 15546Basic Platform Assy FS3SP Concrete SAW Basic Platform AssySCREW, HHC, Washer 1/4- 20 X 3/4 FS3SP Concrete SAW Blade Mist 20 -INCH Assy GUARD, Blade 20 Assy FS3SP Concrete SAW Manual Raise and Lower Assy FS3SP Concrete SAW Manual Raise and Lower Assy FS3SP Concrete SAW Plug KIT Push Assy Part Name QTY. Remarks FS3SP Concrete SAW Plug KIT Self Proppelled Assy 10024 NUT, Nyloc 1/4-20 15340 FS3SP Concrete SAW Plug KIT Self Proppelled AssyBattery BOX Assy FS3SP Concrete SAW Battery BOX Assy15203 FS3SP Concrete SAW Battery BOX Assy10024 NUT, Nylock 1/4 0471 FS3SP Concrete SAW Platform Bare Assy 15069 1503515214 15215Transmission Assy FS3SP Concrete SAW Transmission Assy FS3SP Concrete SAW Transmission Assy CABLE, Throttle 314VTT- 2- 30 1/4 SCREW, HHC, Washer 10- 32 X 5/8FS3SP Concrete SAW Engine Assy 15104 1572915743 15386Console Side FS3SP Concrete SAW Wiring DiagramFS3SP Electric Start Wiring Diagram Rocker Switches Terms and Conditions of Sale Parts Page FAX 310
Top Page Image Contents