Multiquip MT85HS operation manual Symptom Possible Problem Solution

Page 19

 

 

TROUBLESHOOTING

 

 

 

 

TABLE 4. ENGINE TROUBLESHOOTING (continued)

 

 

 

SYMPTOM

POSSIBLE PROBLEM

SOLUTION

 

 

 

Operation not satisfactory

 

 

 

 

 

 

Governor adjustment improper?

Adjust governor to correct lever.

 

 

 

Rotational speed fluctuates.

Governor spring defective?

Clean or replace ignition.

 

 

Fuel flow erratic?

Check fuel line.

 

 

 

 

 

Air taken in through suction

Check suction line.

 

line?

 

 

Recoil starter not working

Dust in rotating part?

Clean recoil starter assembly.

 

 

properly.

Spring spring failure?

Replace sprial spring.

 

 

 

 

TABLE 5. RAMMER TROUBLESHOOTING

SYMPTOM

POSSIBLE PROBLEM

SOLUTION

 

 

 

 

Operating speed of throttle lever

Set throttle lever to correct position.

 

is incorrectly set?

 

 

 

 

 

Oil in excess?

Drain excess oil. Bring to correct level.

Engine rotates but amplituide

 

 

 

 

not uniform or does not strike.

Clutch slips?

Replace or adjust clutch.

 

 

 

 

Spring Failure?

Replace sprial spring.

 

 

 

 

Speed of engine improper?

Adjust engine speed to correct operating RPM setting.

 

 

 

MT85HS RAMMER — OPERATION AND PARTS MANUAL — REV. #9 (01/16/12) — PAGE 19

Page 18 Page 20
Image 19
Page 18 Page 20
Contents
Model MT85HS Proposition 65 Warning MT85HS Rammer Operation and Parts Manual REV. #9 01/16/12 MT85HS Rammer Robin EC12HS Engine Table of ContentsOrdering parts has never been easier Parts Ordering ProceduresSafety Messages Safety InformationGeneral Safety Engine Safety Transporting Safety Definition of Tamping Rammer General InformationSpecifications MT-85HS Rammer SpecificationsMT-85HS Rammer ComponentsRammer Gearbox and Spring Cylinder Oil Bath Operation14 MT85HS Rammer Operation and Parts Manual REV. #9 01/16/12 Normal Shutdown Daily MaintenanceFuel and OIL Lines Engine Troubleshooting Symptom Possible Problem Solution TroubleshootingSymptom Possible Problem Solution Explanation of Codes in the Remarks Column Sample Parts ListTo 3 Units To 5 Units Suggested Spare PartsMikasa Nameplate and DecalsDecal Switch on Decal PRE-CLEANERDecal PRE Cleaner Decal Switch ON-OFFCrankcase and Engine Assy Crank Case Connecting RODThrottle Wire BODY/W-CLEANERGuide Cylinder and Foot Assy Piston END Piston PINStop Ring R-15 Piston RODTank and Handle Assy FILTER, Tank Wire CPHandle Roller Fuel Tank30 MT85HS Rammer Operation and Parts Manual REV. #9 01/16/12 GUARD, OIL Hose STRAP, OIL TankWell NUT M5 WASHER, PW M5Robin EC12HS Engine Crankcase Assy Dowel PIN OIL Seal EC13OIL Seal VC Ball Bearing 6205C3Robin EC12HS Engine Crankshaft and Piston Assy Spring Washer Crank Shaft AssySpacer 0.IT Spacer 0.3TRobin EC12HS Engine Governor Assy Governor ROD Wire BracketGovernor Lever Governor ShaftRobin EC12HS Engine MUFFLER/AIR Cleaner Assy Muffler Bracket Gasket AIR CleanerBracket Cleaner Muffler ComplRobin EC12HS Engine Carburetor Assy Spring AdjusterThrottle Valve Pilot JETRobin EC12HS Engine Recoil Starter Assy Spiral Spring Cylinder BaffleLabelengine Name Tapping BoltRobin EC12HS Engine Electric Device Assy Plug Terminal Wire 22 CPFlywheel Compl GROMMET, HighRobin EC12HS Engine Loose Parts Switch Float CP Freight Policy Terms and Condition of Sale PartsMT85HS Rammer Operation and Parts Manual REV. #9 01/16/12 HERE’S HOW to GET Help
Related manuals
Manual 50 pages 61.04 Kb