Multiquip MT85HS operation manual Safety Information, Safety Messages

Page 6

SAFETY INFORMATION

Do not operate or service the equipment before reading the entire manual. Safety precautions should be followed at all times when operating this equipment.

Failure to read and understand the safety messages and operating instructions could

result in injury to yourself and others.

SAFETY MESSAGES

The four safety messages shown below will inform you about potential hazards that could injure you or others.The safety messages speciﬁcally address the level of exposure to the operator and are preceded by one of four words: DANGER, WARNING, CAUTION or NOTICE.

SAFETY SYMBOLS

DANGER

Indicates a hazardous situation which, if not avoided, WILL result in DEATH or SERIOUS INJURY.

WARNING

Indicates a hazardous situation which, if not avoided, COULD result in DEATH or SERIOUS INJURY.

CAUTION

Indicates a hazardous situation which, if not avoided, COULD result in MINOR or MODERATE INJURY.

NOTICE

Addresses practices not related to personal injury.

Potential hazards associated with the operation of this equipment will be referenced with hazard symbols which may appear throughout this manual in conjunction with safety messages.

PAGE 6 — MT85HS RAMMER — OPERATION AND PARTS MANUAL — REV. #9 (01/16/12)

Image 6

Contents Model MT85HS Proposition 65 Warning MT85HS Rammer Operation and Parts Manual REV. #9 01/16/12 Table of Contents MT85HS Rammer Robin EC12HS EngineParts Ordering Procedures Ordering parts has never been easierSafety Information Safety MessagesGeneral Safety Engine Safety Transporting Safety General Information Definition of Tamping RammerMT-85HS Rammer Specifications SpecificationsComponents MT-85HS RammerOperation Rammer Gearbox and Spring Cylinder Oil Bath14 MT85HS Rammer Operation and Parts Manual REV. #9 01/16/12 Normal Shutdown Maintenance DailyFuel and OIL Lines Troubleshooting Engine Troubleshooting Symptom Possible Problem SolutionSymptom Possible Problem Solution Sample Parts List Explanation of Codes in the Remarks ColumnSuggested Spare Parts To 3 Units To 5 UnitsNameplate and Decals MikasaDecal Switch ON-OFF Decal PRE-CLEANERDecal PRE Cleaner Decal Switch onCrankcase and Engine Assy BODY/W-CLEANER Connecting RODThrottle Wire Crank CaseGuide Cylinder and Foot Assy Piston ROD Piston PINStop Ring R-15 Piston ENDTank and Handle Assy Fuel Tank Wire CPHandle Roller FILTER, Tank30 MT85HS Rammer Operation and Parts Manual REV. #9 01/16/12 WASHER, PW M5 STRAP, OIL TankWell NUT M5 GUARD, OIL HoseRobin EC12HS Engine Crankcase Assy Ball Bearing 6205C3 OIL Seal EC13OIL Seal VC Dowel PINRobin EC12HS Engine Crankshaft and Piston Assy Spacer 0.3T Crank Shaft AssySpacer 0.IT Spring WasherRobin EC12HS Engine Governor Assy Governor Shaft Wire BracketGovernor Lever Governor RODRobin EC12HS Engine MUFFLER/AIR Cleaner Assy Muffler Compl Gasket AIR CleanerBracket Cleaner Muffler BracketRobin EC12HS Engine Carburetor Assy Pilot JET AdjusterThrottle Valve SpringRobin EC12HS Engine Recoil Starter Assy Tapping Bolt Cylinder BaffleLabelengine Name Spiral SpringRobin EC12HS Engine Electric Device Assy GROMMET, High Wire 22 CPFlywheel Compl Plug TerminalRobin EC12HS Engine Loose Parts Switch Float CP Terms and Condition of Sale Parts Freight PolicyMT85HS Rammer Operation and Parts Manual REV. #9 01/16/12 HERE’S HOW to GET Help