Table of Contents
Warnings | . 2 | Spray Tip Selection Chart | 22 |
Installation | . 4 | Air Caps | 22 |
Operation | . 7 | Dimensions | 25 |
General Troubleshooting | 14 | Technical Data | 26 |
Spray Pattern Troubleshooting | 15 | Accessories | 27 |
Service | 16 | Warranty | 28 |
Parts | 18 | Graco Phone Number | 28 |
WARNING
INJECTION HAZARD
Spray from the gun, hose leaks, or ruptured components can inject fluid into your body and cause an extremely serious injury, including the need for amputation. Splashing fluid in the eyes or on the skin can also cause a serious injury.
D Fluid injected into the skin might look like just a cut, but it is a serious injury. Get immediate medi- cal attention.
DDo not point the spray gun at anyone or at any part of the body.
DDo not put hand or fingers over the spray tip.
DDo not stop or deflect fluid leaks with your hand, body, glove, or rag.
DDo not ªblow backº fluid; this is not an air spray gun.
DAlways have the tip guard on the spray gun when spraying.
DCheck the gun diffuser operation weekly.
DBe sure the gun trigger safety operates before spraying.
DLock the gun trigger safety when you stop spraying.
DFollow the Pressure Relief Procedure on page 7 whenever you: are instructed to relieve pres- sure; stop spraying; clean, check, or service the equipment; or install or clean the spray tip.
DTighten all the fluid connections before operating the equipment.
DCheck the hoses, tubes, and couplings daily. Replace worn, damaged, or loose parts immediately. Permanently coupled hoses cannot be repaired; replace the entire hose.
TOXIC FLUID HAZARD
Hazardous fluids or toxic fumes can cause serious injury or death if splashed in the eyes or on the skin, swallowed, or inhaled.
DKnow the specific hazards of the fluid you are using. Read the fluid manufacturer's warnings.
DStore hazardous fluid in an approved container. Dispose of hazardous fluid according to all local, state and national guidelines.
DWear the appropriate protective clothing, gloves, eyewear and respirator.
RECOIL HAZARD
Due to the very high pressure fluid emitted, a strong recoil action will occur when you trigger this gun. If you are unprepared, your hand could be forced back toward your body or you could lose your bal- ance and fall, resulting in serious injury.
2 308640