Multiquip R2000H manual TransmissionV-Belt Adjustment, Scrapers, Cocoa Mats, and Sprinkler Bars

Page 28

TransmissionV-Belt Adjustment

1.Keep pulleys clean and properly aligned using a straight edge. Correct belt tension is essential for the transmission to work properly and efficiently, and for the longevity of the belt.

2.Use a belt tension tester to check the belt tension.

3.Apply the load to theV-belt at the center of the span between the pulleys.The belt deflection should be approximately 1/4" with 3 1/2 lbs. to 4 lbs. load.

CAUTION

DO NOT overtighten the V-belt.This will cause excessive strain on the transmission bearings, resulting in transmission failure.

Scrapers, Cocoa Mats, and Sprinkler Bars

1.Keep roller scraper bars clean. Replace any broken or stretchedspring.Preventaccumulationoftarordebrisaround pivot area.

2.Remove and replace the cocoa mats when badly worn by looseningthescrewsholdingtheminplace.Removetheside panel first to replace the rear mats.

3.Fill the water tank through the large cap on the top rear.Use only clean water or the valve, hoses, and sprinkler bars may become clogged.

Battery

The battery contains acids that can cause injury to the eyes and skin. To avoid eye irritation, always wear safety glasses. Use well insulated gloves when picking up the battery. Use the following guidelines when handling the battery:

1.DO NOT drop the battery. There is the possibility of risk that the battery may explode.

2.DO NOT expose the battery to open flames, sparks, cigarettes etc. The battery contains combustible gases and liquids. If these gases and liquids come in contact with a flame or spark, an explosion could occur.

R2000H — MAINTENANCE

3.ALWAYS keep the battery charged. If the battery is not charged a buildup of combustible gas will occur.

4.ALWAYS keep battery charging and cables in good working condition. Repair or replace all worn cables.

5.ALWAYS recharge the battery in an vented air environment, to avoid risk of a dangerous concentration of combustible gases.

6.ALWAYS wear eye protection and rubber gloves, since the battery contains sulfuric acid which burns skin and eats through clothing.

7.ALWAYS recharge the battery in an vented air environment, to avoid risk of a dangerous concentration of combustible gases.

8.In case the battery liquid (dilute sulfuric acid) comes in contact with clothing or skin, rinse skin or clothing immediately with plenty of water.

9.In case the battery liquid (dilute sulfuric acid) comes in contact with your eyes, rinse eyes immediately with plenty of water, then contact the nearest doctor or hospital, and seek medical attention.

CAUTION:

If your clothing or skin comes in contact with the battery acid, immediately wash off with running water and get medical attention.

zCheck the battery regularly and make sure that each electrolyte level is to the bottom of the vent well (Figure 22). If necessary add only distilled water in a well-ventilated area.

Figure 22. Battery Fluid Levels

PAGE 28 —R2000H RIDE-ON STATIC ROLLER — OPERATION & PARTS MANUAL — REV. #4 (07/24/08)

Page 27 Page 29
Image 28
Page 27 Page 29
Contents Model R2000H Proposition 65WARNING Page Table of Contents Best Deal! Order via Internet Dealers Only Parts Ordering ProceduresOrder via Fax Dealers Only LH 9 in mm RH 3.25 in mm LH 1.75 in mmDrive to rear roll 25 x 7 x 7 in .5 x17.8 x17.8 cmR2000H Specifications Engine R2000H Dimensions R2000H Roller DimensionsInjury to yourself and others Seriously injured if you do not follow directionsAlways wear approved respiratory protection InstructionsRules for Safe Operation Rules for Safe Operation Always wear seat beltsNever stand below roller when it is being lifted EmergenciesOperation and Safety Decals Machine Safety DecalsDo not operate this roller on slippery or wet surfaces Recommended SlopeTipping Rollovers Tipping RolloverPage R2000H Roller Components Roller ComponentsTie-Down Transport Points Free Wheel Engagement PinAttach a chain or suitable tie-down R2000H Engine Components R2000H Inspection Before StartingEngine Oil Check Capacity is 400 cc Reference manufacturer engineWater System Check Place the Choke Lever in the Closed position Sit down in the operators seatStarting the Engine Ignition Switch R2000H OperationPlace the transmission lever in the neutral position Water Sprinklers ControlEmergency Shut-Down Lubrication R2000H MaintenanceHydrostatic Transmission Transmission Control Lever Adjustment Steering AdjustmentDrive Chains Tension Adjustment Drive ChainsUse a belt tension tester to check the belt tension TransmissionV-Belt AdjustmentScrapers, Cocoa Mats, and Sprinkler Bars R2000H Preparation for Long -TERM Storage Roller StorageR2000H Troubleshooting Roller R2000H Troubleshooting Engine Engine TroubleshootingNO. Column Part NO. ColumnQTY. Column Remarks ColumnR2000H Suggested Spare Parts R2000H Name Plate and Decals Name Plate and DecalsDECAL, MQ R2000H Left DECAL, MQ R2000H RightDECAL, MQ DECAL, MQ MultiquipR2000H Brake Assy Brake AssyAdjustable Yoke LEVER, Parking BrakeCAP Screw 5/16 SpacerR2000H Steering Assy Steering AssyCAP Hexnut 5/8Flatwasher 5/8 Washer 5/8R2000H Chassis and Covers Assy Chassis & Covers AssyMain Body Frame GUARD, RearPANEL, Left Side PLATE, ShifterR2000H Battery Assy Battery AssyBattery CLAMP, BatteryCAP Screw 3/8 REDR2000H Rear Drum Assy Rear Drum AssySprocket 70 Tooth BearingSCREW, HEX 5/8 R2000H Drive System Assy Drive System AssyHonda GX240K1QAE2 WASHER, Flat 3/8Clip PULLEY, Engine 6 MMR2000H Transmission Assy Transmission AssyAdjustment ROD ROD, AdjustmentPUMP, Hydrostatic LEVER, Free Flow ReliefR2000H Water System Assy Water System AssyTANK, Water Washer 5/16 Flat WWasher 5/16 Lock CAP, Plastic Water TankHonda GX240K1QAE2 Engine AIR Cleaner Assy AIR Cleaner AssyCOVER, AIR Cleaner GROMMET, AIR CleanerCOLLAR, AIR Cleaner Collar B, AIR CleanerHonda GX240K1QAE2 Engine Camshaft Assy Camshaft AssySPRING, Weight Return ROD PushARM Valve Rocker Lifter ValveHonda GX240K1QAE2 Engine Carburetor Assy Carburetor AssyPLATE, Lever Setting Gasket SETValve SET, Float Float SETHonda GX240K1QAE2 Engine Control Assy Control AssyARM, Governor ROD, GovernorSPRING, Governor SPRING, Throttle ReturnHonda GX240K1QAE2 Engine Crankcase Cover Assy Crankcase Cover AssyWEIGHT, Governor HOLDER, Governor WeightPIN, Governor Weight GASKET, Case CoverHonda GX240K1QAE2 Engine Crankshaft Assy Crankshaft AssyWEIGHT, Balancer 90745ZE2600 KEY 6.3 X 6.3 X 961006206000Honda GX240K1QAE2 Engine Cylinder Barrel Assy Cylinder Barrel AssySwitch ASSY., OIL Level SHAFT, Governor ARMBOLT, Drain Plug OIL SealHonda GX240K1QAE2 Engine Cylinder Head Assy Cylinder Head AssyGUIDE, VALVE, OS, Optional GUIDE, EX. VALVE, OS, OptionalCLIP, Valve Guide GASKET, Cylinder HeadHonda GX240K1QAE2 Engine FAN Cover Assy FAN Cover AssyCLIP, Wire Harness CLIP, TubeShroud GROMMET, Drain HoleHonda GX240K1QAE2 Engine Flywheel Assy Flywheel AssyFAN, Cooling Flywheel CompNUT, Special 16MM KEY, Special WoodruffHonda GX240K1QAE2 Engine Fueltank Assy Fuel Tank AssyRubber Supporter 107MM JOINT, Fuel TankGASKET, Fuel Filler CAP FILTER, FuelHonda GX240K1QAE2 Engine Ignition Coil Assy Ignition Coil AssyCLAMP, Wire GROMMET, WireWIRE, Stop Switch 370MM HOLDER, Stop Switch WireHonda GX390K1QAE2 Starter Motor Assy Starter Motor AssyWIRE, Water Cover Contactor AssyArmature Clutch OverrunningHonda GX240K1QAE2 Control BOX Assy Control BOX Assy CLIP, Purse LockTUBE, Fastener FUSE, Blade 15A Alert UNIT, OILHonda GX240K1QAE2 Engine Muffler Assy Muffler AssyMuffler Protector COMP., MufflerPROTECTOR, EX. Pipe PIPE, EXHonda GX240K1QAE2 Engine Piston Assy Piston AssyBOLT, Connecting ROD Ring SET, PISTON, STDRing SET, PISTON, 0.75, Optional PISTON, StandardHonda GX240K1QAE2 Engine Recoil Starter Assy Recoil Starter AssyPULLEY, Recoil Starter RATCHET, StarterSPRING, Friction SPRING, Starter ReturnHonda GX240K1QAE2 Engine Engine Labels Engine LabelsEMBLEM, Internal LABEL, CautionMARK, CHOKE, External MARK, OIL ALERT, ETerms and Conditions of Sale Parts Page HERE’S HOW to GET Help Your Local Dealer is
Related manuals
Manual 90 pages 18.24 Kb

R2000H specifications

The Multiquip R2000H is a versatile and robust portable generator designed to meet the demands of construction sites, rental industries, and various outdoor events. Known for its reliability and performance, this generator stands out with several key features and technologies that cater to diverse power needs.

One of the main features of the R2000H is its powerful engine. The generator is equipped with a reliable Honda GX390 engine, providing a starting output of 2000 watts and a running output of 1800 watts. This ensures ample power to run essential tools and equipment, such as drills, saws, and lights, effectively and efficiently.

The R2000H showcases advanced inverter technology, which offers clean and stable power that is crucial for sensitive electronic equipment. This feature makes it ideal for job sites where precision and protection of equipment are paramount. Inverter technology also ensures fuel efficiency, allowing for longer run times on a single tank of gas, making it an economical choice for extended use.

Portability is another significant characteristic of the Multiquip R2000H. It is designed with a compact structure and lightweight construction, making it easy to transport from one location to another. The integrated wheels and folding handle allow for smooth mobility, thus enhancing its usability on various job sites or recreational activities.

Additionally, the R2000H is constructed with durability in mind. The robust frame protects the generator from the rigors of job site challenges, while also incorporating features like a quiet muffler to reduce operating noise. This is particularly beneficial for users who need to operate the generator in noise-sensitive environments.

User-friendly controls make the R2000H accessible for novice users, while also providing necessary functionalities for experienced operators. The intuitive panel features multiple outlets, enabling the simultaneous use of different tools, and an easy-to-read fuel gauge that allows users to monitor fuel levels with confidence.

Overall, the Multiquip R2000H combines power, efficiency, and convenience, making it an excellent choice for various applications. Whether powering professional tools on a construction site or providing backup power during outdoor events, this generator is designed to deliver reliable performance with outstanding features and technologies.
Top Page Image Contents