Hobart Welding Products H-10 GUN, 180 manual Welding arc not stable Wire slipping in drive rolls

Page 44

Problem

Probable Cause

Remedy

 

 

 

Welding arc not stable.

Wire slipping in drive rolls.

Adjust pressure setting on wire feed rolls. Replace worn

 

 

drive rolls if necessary.

 

 

 

 

Wrong size gun liner or contact tip.

Match liner and contact tip to wire size and type.

 

 

 

 

Incorrect voltage setting for selected wire feed speed on

Readjust welding parameters.

 

welding power source.

 

 

 

 

 

Loose connections at the gun weld cable or work cable.

Check and tighten all connections.

 

 

 

 

Gun in poor shape or loose connection inside gun.

Repair or replace gun as necessary.

 

 

 

OM-925 Page 40

Image 44
Contents Processes DescriptionFrom Hobart to You Table of Contents − Parts List Symbol Usage Marks a special safety messageArc Welding Hazards Electric Shock can killARC Rays can burn eyes and skin Welding can cause fire or explosionFlying Metal can injure eyes Buildup of GAS can injure or killCalifornia Proposition 65 Warnings About Pacemakers Principal Safety StandardsEMF Information Signification des symboles − Consignes DE Sécurité − À Lire Avant UtilisationLES Décharges Électriques peuvent être mortelles LES Fumées ET LES GAZ peuvent être dangereuxLE Soudage peut causer un incen- die ou une explosion LES Particules Projetées peu- vent blesser les yeuxLES Pièces Chaudes peuvent cau- ser des brûlures graves LE Bruit peut affecter l’ouïeRisque D’INCENDIE OU D’EXPLO LA Chute DE L’APPAREIL peut blesser’EMPLOI Excessif peut Faire LES Pièces Mobiles peuvent cau- ser des blessuresConsignes relatives aux stimulateurs cardiaques Principales normes de sécuritéInformation sur les champs électromagnétiques − Specifications Symbols And DefinitionsSpecifications − DefinitionsDuty Cycle And Overheating AmperesOutput Duty Cycle % VAC Model Output AmperesAmperage Volt-Ampere CurvesVoltage Installing Work Clamp − InstallationInstalling Welding Gun Process/Polarity Table Changing PolarityInstalling Gas Supply Special installation may be SectionDo not move or operate unit where it could tip Electrical Service Guide For 230 VAC Model Installing Wire Spool And Adjusting Hub TensionThreading Welding Wire Hold wire tightly to keep it From unraveling− Operation ControlsWeld Parameter Chart For 115 VAC Model 217 618-A Weld Parameter Chart For 230 VAC Model 217 754-B − Maintenance &TROUBLESHOOTING Routine MaintenanceOverload Protection Drive Motor ProtectionReplacing Gun Contact Tip Changing Drive Roll Or Wire Inlet GuideTurn Off power before replacing contact tip To Reassemble Gun Cleaning Or Replacing Gun LinerDisconnect gun from unit Replacing Switch And/Or Head Tube Does not run Troubleshooting TableTrouble Remedy − Electrical Diagram Circuit Diagram For 115 VAC ModelCircuit Diagram For 230 VAC Model − MIG Welding Gmaw Guidelines Typical MIG Process ConnectionsTypical MIG Process Control Settings Wire Size Amperage RangeThickness to Amperage a Select VoltageHolding And Positioning Welding Gun Conditions That Affect Weld Bead Shape Gun Movement During Welding Poor Weld Bead CharacteristicsGood Weld Bead Characteristics Troubleshooting − Excessive Spatter Troubleshooting − PorosityTroubleshooting − Excessive Penetration Possible Causes Corrective ActionsTroubleshooting − Burn-Through Troubleshooting − Lack Of PenetrationTroubleshooting − Incomplete Fusion Troubleshooting − Waviness Of Bead Troubleshooting − DistortionTroubleshooting Guide For Semiautomatic Welding Equipment Wire does not feedCommon MIG Shielding Gases ApplicationWelding arc not stable Wire slipping in drive rolls OM-925 − Parts List Main AssemblyDia Part Description Quantity Dia Part Description Quantity Mkgs H-10 Gun 195Optional Drive Rolls OptionsService SupportContact your Distributor for Hobart Welding Products