Multiquip MVH-306DS Battery Cable Connection Option, Long Term Storage, Checking Fuel Filter

Page 25

MAINTENANCE

Battery fluid will be lost through continuous charging and discharging.

Discontinue charging if the electrolyte temperature exceeds 117° F (45° C)

NOTICE

During summer much more battery fluid is lost than in winter. Before starting, check battery electrolyte levels and replenish with distilled water to the upper mark on the battery.

BATTERY CABLE CONNECTION (Option)

1.Take off the battery cover by removing the M6 nuts (Figure 32).

2.When removing cable, disconnect the ground side (normally negative) first (Figure 34).

3.When installing cable connect the ground side (normally negative) last.

Figure 34. Battery Removal

LONG TERM STORAGE

When storing your compactor for long periods do the following:

Run the engine at idle spped for 3-5 minutes.

Stop the engine. Drain the engine crankcase oil while the engine is still warm. Fill Engine crankcase with fresh oil.

Remove the rubber plug (Figure 36) on the rocker arm cover and add about 2 cc of lube oil. Reinstall rubber plug.

Figure 36. Decompression Lever

For recoil type compactors, push the decompression down (non-decompression position) and hold it while you pull the recoil starter grip(Figure 37) rope 2 or 3 times. DO NOT start the engine.

CHECKING FUEL FILTER

1.Clean the fuel filter (Figure 35) every 3 months or 200 hours.

2.Replace fuel filter every 6 months or 400 hours.

3.To clean the fuel filter, loosen the nuts of the fuel cock and pull- outthefilterfromtheF.O.tankfillerport.Washthefilterthroughly with diesel fuel oil.

4.Re-install fuel filter and connect all associated hardware.

Figure 35. Fuel Filter

Figure 37. Recoil Starter Grip

For electric start type compactors, turn the engine for 2 or 3 seconds with the decompression lever set in the non- decompression position, and the starter key at the START position. DO NOT start the engine.

Pull the decompression lever up. Pull the recoil starter grip slowly. STOP when it feels tight.This closes the intake and exhaust valves (compression position) , and helps prevents ruts from forming.

Wipe any oil or dirt that may have accumulated on the compactor.

Store compactor in a cool dry place out of the reach of children or unauthorized personnel.

Troubleshooting

See Tables 8 (engine) and 9 (plate compactor) on proceeding pages for engine and plate compactor troubleshooting guide.

MVH306D/DS PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #11 (02/04/14) — PAGE 25

Image 25
Contents Models MVH-306D Recoil Start MVH-306DS Electric Start Diesel engine exhaust and some Proposition 65 WarningPage Mikasa MVH-306D/DS Reversible Plate Compactor Table of ContentsOrdering parts has never been easier Parts Ordering ProceduresSafety Messages Safety InformationGeneral Safety Compactor Safety Fuel Safety Transporting Safety MVH-306D/DS Reversible Plate Compactor Specifications SpecificationsMVH-306D/DS Reversible Plate Compactor Dimensions DimensionsGeneral Information MVH-306D/DS Reversible Plate Compactor Components ComponentsEngine Components Basic EngineBefore Starting InspectionChecking Engine Oil Level Checking the Hydraulic Oil LevelChecking The Fuel Explosive FuelReleasing the Handle OperationStarting the Engine Electric Start OptionRecoil Start TravelingStowing the Handle Normal ShutdownInspection and Maintenance ServiceTables MaintenanceDaily Service  Reinstalling the V-belt Engine Oil ReplacementAir Filter Every 6 Months or 400 Hours  Checking ClutchDraining Hydraulic Oil Vibrator Oil Level CheckAdding Hydraulic Oil Battery Charging Bleeder Plug Battery Maintenance OptionTroubleshooting Battery Cable Connection OptionLong Term Storage Checking Fuel FilterEngine Troubleshooting TroubleshootingTroubleshooting Compactor Explanation of Code in Remarks Column Sample Parts ListMVH-306W/YANMAR L-70EE Diesel Engine Suggested Spare PartsNameplate and Decals Nameplate and DecalsPart Name QTY Remarks Vibrating Plate Assy Part Name Base and Engine Assy Base & Engine Assy Base and Engine Assy Union TIP, Drain Vibrator Assy Vibrating Case Control Handle Assy Handle Bracket Control Handle Assy COLUMN, Handle Hand Pump Assy Accumlator Includes Items W/# Battery ASSY. Option CRADLE, Battery Electric Device Assy Battery Cord 400L Yanmar L-70EE Cylinder Block Assy COVER, Starter Yanmar L-70EE Cylinder Head and Cover Assy Cylinder Head & Cover Assy Yanmar L-70EE Muffler Assy Gasket NON ASB Yanmar L-70EE AIR Cleaner Assy COVER, AIR Cleaner Yanmar L-70EE CRANKSHAFT, PISTON, Camshaft Assy CRANKSHAFT, Piston & Camshaft Assy Yanmar L-70EE LUB OIL Pump and Governor Assy LUB. OIL Pump & Governor Assy Yanmar L-70EE Cooling and Starting Device Assy Cooling & Starting Device Assy Yanmar L-70EE Fuel Injection Pump Assy Plate Yanmar L-70EE Fuel Tank and Fuel Line Assy Fuel Tank & Fuel Line Assy Yanmar L-70EE Starting Motor and Dynamo Assy Starting Motor & Dynamo Assy Yanmar L-70EE TOOL, LABEL, and Gasket Assy TOOL, Label & Gasket SET Assy Terms and Conditions of Sale Parts Page HERE’S HOW to GET Help