Multiquip MVH-306DS manual Compactor Safety

Page 8

SAFETY INFORMATION

COMPACTOR SAFETY

DANGER

„NEVER operate the equipment in an explosive atmosphere or near combustible materials.An explosion or fire could result causing severe bodily harm or even death.

WARNING

„NEVER disconnect any emergency or safety devices. These devices are intended for operator safety. Disconnection of these devices can cause severe injury, bodily harm or even death. Disconnection of any of these devices will void all warranties.

CAUTION

„NEVER lubricate components or attempt service on a running machine.

NOTICE

„ALWAYS keep the machine in proper running condition.

„Fix damage to machine and replace any broken parts immediately.

„ALWAYS store equipment properly when it is not being used. Equipment should be stored in a clean, dry location out of the reach of children and unauthorized personnel.

ENGINE SAFETY

DANGER

„The engine fuel exhaust gases contain poisonous carbon monoxide. This gas is colorless and odorless, and can cause death if inhaled.

„The engine of this equipment requires an adequate free flow of cooling air. NEVER operate this equipment in any enclosed or narrow

area where free flow of the air is restricted. If the air

flow is restricted it will cause injury to people and property and serious damage to the equipment or engine.

WARNING

„DO NOT place hands or fingers inside engine compartment when engine is running.

„NEVER operate the engine with heat shields or guards removed.

„ Keep fingers, hands hair and clothing away from all moving parts to prevent injury.

„DO NOT remove the radiator cap while the

engine is hot. High pressure boiling water will gush out of the radiator and severely scald any persons in the general area of the compactor.

„ DO NOT remove the coolant drain plug while the engine is hot. Hot coolant will gush out of the coolant tank and severely scald any persons in the general area of the compactor.

„DO NOT remove the engine oil drain plug while the engine is hot. Hot oil will gush out of the oil tank and severely scald any persons in the general area of the compactor.

CAUTION

„NEVER touch the hot exhaust manifold,

muffler or cylinder. Allow these parts to cool before servicing equipment.

NOTICE

„NEVER run engine without an air filter or with a dirty air filter. Severe engine damage may occur. Service air filter frequently to prevent engine malfunction.

„NEVER tamper with the factory settings of the engine or engine governor. Damage to the engine or equipment can result

if operating in speed ranges above the maximum allowable.

„NEVER tip the engine to extreme angles during lifting as it may cause oil to gravitate into the cylinder head, making the engine start difficult.

PAGE 8 — MVH306D/DS PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #11 (02/04/14)

Image 8
Contents Models MVH-306D Recoil Start MVH-306DS Electric Start Proposition 65 Warning Diesel engine exhaust and somePage Table of Contents Mikasa MVH-306D/DS Reversible Plate CompactorParts Ordering Procedures Ordering parts has never been easierSafety Information Safety MessagesGeneral Safety Compactor Safety Fuel Safety Transporting Safety Specifications MVH-306D/DS Reversible Plate Compactor SpecificationsDimensions MVH-306D/DS Reversible Plate Compactor DimensionsGeneral Information Components MVH-306D/DS Reversible Plate Compactor ComponentsBasic Engine Engine ComponentsInspection Before StartingChecking Engine Oil Level Checking the Hydraulic Oil LevelExplosive Fuel Checking The FuelOperation Releasing the HandleStarting the Engine Electric Start OptionTraveling Recoil StartNormal Shutdown Stowing the HandleDaily Service MaintenanceInspection and Maintenance ServiceTables Engine Oil Replacement  Reinstalling the V-beltAir Filter Every 6 Months or 400 Hours  Checking ClutchAdding Hydraulic Oil Vibrator Oil Level CheckDraining Hydraulic Oil Bleeder Plug Battery Maintenance Option Battery ChargingBattery Cable Connection Option TroubleshootingLong Term Storage Checking Fuel FilterTroubleshooting Engine TroubleshootingTroubleshooting Compactor Sample Parts List Explanation of Code in Remarks ColumnSuggested Spare Parts MVH-306W/YANMAR L-70EE Diesel EngineNameplate and Decals Nameplate and DecalsPart Name QTY Remarks Vibrating Plate Assy Part Name Base and Engine Assy Base & Engine Assy Base and Engine Assy Union TIP, Drain Vibrator Assy Vibrating Case Control Handle Assy Handle Bracket Control Handle Assy COLUMN, Handle Hand Pump Assy Accumlator Includes Items W/# Battery ASSY. Option CRADLE, Battery Electric Device Assy Battery Cord 400L Yanmar L-70EE Cylinder Block Assy COVER, Starter Yanmar L-70EE Cylinder Head and Cover Assy Cylinder Head & Cover Assy Yanmar L-70EE Muffler Assy Gasket NON ASB Yanmar L-70EE AIR Cleaner Assy COVER, AIR Cleaner Yanmar L-70EE CRANKSHAFT, PISTON, Camshaft Assy CRANKSHAFT, Piston & Camshaft Assy Yanmar L-70EE LUB OIL Pump and Governor Assy LUB. OIL Pump & Governor Assy Yanmar L-70EE Cooling and Starting Device Assy Cooling & Starting Device Assy Yanmar L-70EE Fuel Injection Pump Assy Plate Yanmar L-70EE Fuel Tank and Fuel Line Assy Fuel Tank & Fuel Line Assy Yanmar L-70EE Starting Motor and Dynamo Assy Starting Motor & Dynamo Assy Yanmar L-70EE TOOL, LABEL, and Gasket Assy TOOL, Label & Gasket SET Assy Terms and Conditions of Sale Parts Page HERE’S HOW to GET Help