Dyna-Glo RMC-KFA65T WARNINGS 1.RISK OF INDOOR AIR POLLUTION, Risk Of Burns/Fire/Explosion

Page 2
NEVER LEAVE THE HEATER

NEVER LEAVE THE HEATER

UNATTENDED WHILE BURNING!

DANGER - IMPROPER USE OF THIS HEATER CAN RESULT IN SERIOUS INJURY OR DEATH FROM BURNS, FIRE, EXPLOSION, ELECTRICAL SHOCK AND/OR CARBON MONOXIDE POISONING.

WARNINGS:

1.RISK OF INDOOR AIR POLLUTION!

Use this heater only in well ventilated areas. Provide at least a three-square foot (2,800 sq. cm.) opening of fresh outside air for each 100,000 BTU/hr. of heater rating.

People with breathing problems should consult a physician before using the heater.

Carbon monoxide poisoning: Early signs of carbon monoxide poisoning resemble the flu, with headaches, dizziness and/or nausea. If you have these signs, the heater may not be working properly. Get fresh air at once! Have the heater serviced. Some people are more affected by carbon monoxide than others. These include pregnant women, persons with heart or lung disease or anemia, those under the influence of alcohol, or those at high altitudes.

Never use this heater in living or sleeping areas.

2.RISK OF BURNS/FIRE/EXPLOSION!

NEVER use any fuel other than 1-K kerosene in this heater. #1 fuel oil is the only acceptable substitute.

NEVER use fuel such as gasoline, benzene, paint thinners or other oil compounds in this heater.

(RISK OF FIRE OR EXPLOSION)

NEVER use this heater where flammable vapors may be present.

NEVER refill the heaters fuel tank while heater is operating or is still hot.

This heater is EXTREMELY HOT while in operation. Keep all combustible materials away from heater. Minimum Clearances: Outlet: 8 feet (250cm) / Sides, top and rear: 4 feet (125cm)

NEVER block air inlet (rear) or air outlet (front) of heater.

NEVER use duct work in front or behind of heater.

NEVER move or handle heater while still hot.

NEVER transport heater with fuel in it’s tank.

When used with an optional thermostat or if equipped with a thermostat heater may start at any time.

ALWAYS locate heater on a stable and level surface.

ALWAYS keep children and animals away from heater.

Bulk fuel storage should be a minimum of 25 ft. from heaters, torches, portable generators or other sources of ignition. All fuel storage should be in accordance with federal, state or local authorities having jurisdiction.

3.RISK OF ELECTRIC SHOCK!

Use only the electrical power (voltage and frequency) specified on the model plate of the heater.

Use only a three-prong, grounded outlet and extension cord.

ALWAYS install the heater so that it is not directly exposed to water spray, rain, dripping water or wind.

ALWAYS unplug the heater when not in use.

CALIFORNIA RESIDENTS: This heater produces carbon monoxide, which is listed by the State of California as a reproductive toxin under Proposition 65.

MASSACHUSETTS RESIDENTS: Massachusetts state law prohibits the use of this heater in any building which is used in whole or in part for human habitation. Use of this heating device in Massachusetts requires local fire dept. permit (M.E.L.C. 148, Section 10A.)

CANADIAN RESIDENTS: Use of this heater shall be in accordance with authorities having jurisdiction and CSA Standard B139.

NEW YORK CITY RESIDENTS: For use only at construction sites in accordance with applicable NYC codes under NYCFD certificate of approval

1

Image 2
Contents MODEL RMC-KFA45T, RMC-KFA65T, RMC-KFA120T PORTABLE FORCED AIR HEATERSRMC-KFA170T, RMC-KFA210T CFM RMC INTERNATIONAL 3501 W. HOWARD ST3.RISK OF ELECTRIC SHOCK WARNINGS 1.RISK OF INDOOR AIR POLLUTION2.RISK OF BURNS/FIRE/EXPLOSION NEVER LEAVE THE HEATER UNATTENDED WHILE BURNINGINTRODUCTION 2. FEATURESPAGE # NEVER LEAVE THE HEATER UNATTENDED WHILE BURNINGNEVER LEAVE THE HEATER UNATTENDED WHILE BURNING Handle3.UNPACKING AND ASSEMBLY Tools Required NEVER LEAVE THE HEATER UNATTENDED WHILE BURNINGTools Required Handle Screw Hot Air Outlet Fuel Tank Flange 4. KEROSENE 1-KNEVER LEAVE THE HEATER UNATTENDED WHILE BURNING Air Inlet Wheel Support Frame Nut Wheel AxleNEVER LEAVE THE HEATER UNATTENDED WHILE BURNING The Safety System5.OVERVIEW OF HEATERS DESIGN FUSE TYPENEVER LEAVE THE HEATER UNATTENDED WHILE BURNING 6. FUELING YOUR HEATEROPERATION A. FUEL TANK 9.MAINTENANCE8. LONG TERM STORAGE OF YOUR HEATER B. AIR INTAKE FILTERE. NOZZLE C. AIR OUTPUT FILTER, LINT FILTERD. FAN BLADES NEVER LEAVE THE HEATER UNATTENDED WHILE BURNINGF. SPARK PLUG NEVER LEAVE THE HEATER UNATTENDED WHILE BURNINGG. PHOTOCELL NEVER LEAVE THE HEATER UNATTENDED WHILE BURNINGFuel Line Side Cover H. FUEL FILTERNEVER LEAVE THE HEATER UNATTENDED WHILE BURNING Fuel LineI FUEL VALVE NEVER LEAVE THE HEATER UNATTENDED WHILE BURNINGAdaptor Nozzle I. PUMP PRESSURE ADJUSTMENT NEVER LEAVE THE HEATER UNATTENDED WHILE BURNINGPOSSIBLE CAUSE 10. TROUBLE SHOOTING GUIDETROUBLE CORRECTIVE ACTIONB WIRING DIAGRAM RMC-KFA120T 11. WIRING DIAGRAMA WIRING DIAGRAM RMC-KFA45T / RMC-KFA65T NEVER LEAVE THE HEATER UNATTENDED WHILE BURNINGD WIRING DIAGRAM RMC-KFA210T 11. WIRING DIAGRAMC WIRING DIAGRAM RMC-KFA170T NEVER LEAVE THE HEATER UNATTENDED WHILE BURNINGNEVER LEAVE THE HEATER UNATTENDED WHILE BURNING 12. SPECIFICATIONSMODEL NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING 13. EXPLODED PARTS DRAWING RMC-KFA210T Model Only NEVER LEAVE THE HEATER UNATTENDED WHILE BURNINGNEVER LEAVE THE HEATER UNATTENDED WHILE BURNING FA1010 all models ACCESSORIESAir Pressure Gauge ThermostatDESCRIPTION 14. PARTS LIST RMC-KFA210T Model OnlyNEVER LEAVE THE HEATER UNATTENDED WHILE BURNING RMC-KFA210TFA1010 all models ACCESSORIESAir Pressure Gauge Thermostat2 RMC-KFA120T/170T/210TMODEL 14. PARTS LIST WHEELS AND HANDLE1 RMC-KFA45T/65TMODELS NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING4221 EDITION07/03 Rev