Monessen Hearth DFS32NVC, DFS36NVC, DFS42NVC, DFS32PVC, DFS42PVC, DFS36PVC Checking the Burner Flame

Page 26

CHECKING THE BURNER FLAME

In normal operation at full rate after 15 minutes, the following ﬂame appearances should be observed:

Figure 29 - Correct Appearance of Rear Flames of Charred Timber

Burner will have a random pattern of yellow flames as shown in Figure 29. There should be glowing embers on the front burner. Note: The front ﬂames and embers will be an opaque orange color during the burn off time.

26

71D0532

Image 26

Contents What to do if YOU Smell GAS Read and Save These InstructionsContents Owner Important Safety InformationInstaller From Product Features OperationNatural GAS PROPANE/LPGSpecifications Make Sure YOU have Received ALL Parts What YOU will Need for InstallationGetting Started General Installation Information Firebox Dimensions with Screen and Log SetsCodes Adequate Combustion and Ventilation AIRBTU/Hr = 15 1/ 2 x 12 x 1000 = 29760 BTU/Hr Installing Canopy Removing ScreenDo not Install this Model in a Bedroom or Bathroom Location of FireplaceClearances and Height Requirements 21/2 16 1921Fireplace Framing Framing surfaceﬁreplace must be installed giving Connecting the GAS Flexible Tube Manual Shutoff Gas Supply Inlet ValveChecking GAS Pressure MILLI-VOLT Control FigureOperate Electrical WiringConnecting Optional Wall Switch Complete MILLI-VOLT System Check Connecting Remote ReceiverChecking System Operation LOG Placement Installing Charred Timber Logs on BurnerInstalling Left Base Log #3 Installing Left Top Log #5 Installing Right Top Log #6 Placing Rock WoolMILLI-VOLT Control Flame AppearanceChecking the Pilot Flame Checking the Burner Flame Correct Appearance of Rear Flames of Charred TimberOperating Instructions For Your Safety Read Before Lighting MILLI-VOLT Control Lighting Instructions Operating InstructionsOperating Instructions and Cleaning and Servicing Cleaning and ServicingForced AIR KIT Blower and Other Optional EquipmentOptional Equipment Optional TrimIllustrated Parts Breakdown Charred Timber LogsIllustrated Parts Breakdown Accessories Sold Separately Replacement Parts ListBurner Assembly Illustrated Parts Breakdown BRC36 BRC42 Troubleshooting Observed Problem Possible Cause RemedyODS/pilot lights, but flame Trim Installation Trim Installation For USE of Optional AK-4 Outside AIR KIT Combustion AIRModel AK-4 Combustion AIR Assembly Insulation Ring to Left Side of FireplaceInstalling Model 403 Duct Connector 71D0532 Five Year Warranty Basic Warranty