
HOW TO ORDER REPAIR PARTS
Parts can be ordered only through your service person or dealer. For best results, the service person or dealer should order parts through the distributor. Parts can be shipped directly to the service person/dealer.
All parts listed in the Parts List have a Part Number. When ordering parts, first obtain the Model Number from the name plate on your equipment. Then determine the Part Number (not the Index Number) and the Description of each part from the following appropriate illustration and list. Be sure to give all this information.
Furnace Model Number |
|
|
| Part Description |
|
| |||
|
|
|
| ||||||
Furnace Serial Number |
|
|
| Part Number |
|
|
| ||
Type of Gas (Propane or Natural) |
|
|
|
|
|
|
Do not order bolts, screws, washers or nuts. They are standard hardware items and can be purchased at any local hardware store. Shipments contingent upon strikes, fires and all causes beyond our control.
Empire Comfort Systems, Inc. Nine Eighteen Freeburg Ave. Belleville, IL
PARTS LIST
PLEASE NOTE: When ordering parts, it is very important that part number and description of part coincide.
| INDEX | PART |
| INDEX | PART |
|
| NO. | NUMBER | DESCRIPTION | NO. | NUMBER | DESCRIPTION |
|
|
|
|
|
|
|
1 | SHROUD TOP | 39 | FLAME ROLLOUT SWITCH | |||
2 | SHROUD SIDE RIGHT | 40 | BURNER COMPARTMENT ACCESS | |||
3 | AIR FILTER |
|
| PANEL | ||
4 | FILTER RETAINER | 41 | BURNER COMPARTMENT | |||
5 | WALL MOUNTING BRACKET | 42 | GAS VALVE (NAT GAS) | |||
6 | WALL BRACKET - 2 REQUIRED | 42 | GAS VALVE (LP GAS) | |||
7 | CONTROL DOOR PIN - 2 REQUIRED | 43 | VALVE BRACKET ASSEMBLY | |||
8 | 19676 | CONTROL DOOR ASSEMBLY | 44 | MANIFOLD ASSEMBLY | ||
9 | CASING TOP | 44 | MANIFOLD ASSEMBLY | |||
10 | BLOWER HOUSING - 2 REQUIRED | 45 | ORIFICE (NAT GAS) - 1 REQUIRED ON | |||
11 | BLOWER WHEEL - 2 REQUIRED |
|
| |||
12 | BLOWER MOTOR | 45 | ORIFICE (LPG GAS) - 1 REQUIRED ON | |||
13 | MOTOR BASE WASHER - 4 REQUIRED |
|
| |||
14 | LIMIT SWITCH | 45 | ORIFICE (NAT GAS) - 2 REQUIRED ON | |||
15 | INNER TOP |
|
| |||
16 | CONTROL KNOB | 45 | ORIFICE (LPG GAS) - 2 REQUIRED ON | |||
17 | ON/OFF SWITCH |
|
| |||
18 | 19561 | JUNCTION BOX | 46 | MANIFOLD GASKET | ||
19 | JUNCTION BOX COVER | 47 | OBSERVATION HOLE COVER ASSEMBLY | |||
20 | TRANSFORMER | 48 | OBSERVATION HOLE COVER GASKET | |||
21 | PRESSURE SWITCH | 49 | FRONT SHIELD ASSEMBLY | |||
22 | CONTROL BOARD | 50 | BOTTOM SHIELD | |||
23 | TEMPERATURE CONTROL BOARD | 51 | FRONT GRILL ASSEMBLY | |||
24 | CASING WELDED ASSEMBLY | 52 | CASING FRONT ASSEMBLY | |||
25 | STRAIN RELIEF BUSHING | 53 | HOSE CLAMP - 4 REQUIRED | |||
26 | CORD SET | 54 | INLET HOSE | |||
27 | INNER END | 55 | OUTLET ELBOW | |||
28 | CASING SIDE - 2 REQUIRED | 56 | VENT PAN ASSEMBLY | |||
29 | 15790 | COLLECTOR BOX | 57 | INLET CAP | ||
29 | 15791 | COLLECTOR BOX | 58 | WALL PLATE GASKET - INSIDE | ||
30 | INDUCER WHEEL | 59 | WALL PLATE GASKET - OUTSIDE | |||
31 | INDUCER BLOWER HOUSING | 60 | WALL PLATE - OUTSIDE | |||
32 | INDUCER MOTOR | 61 | TUBE SPACER | |||
33 | 15783 | EXCHANGER ASSEMBLY | 62 | END CAP ASSEMBLY | ||
33 | 15784 | EXCHANGER ASSEMBLY | 63 | SHROUD SIDE LEFT | ||
34 | 19565 | IGNITOR KIT | NS | BAFFLE - 1 REQUIRED ON | ||
37 | FLAME SENSOR | NS | CONDENSATE KIT | |||
38 | BURNER (2 REQUIRED ON | NS | ELBOW KIT | |||
|
|
|
| NS | WIRE ASSEMBLY - CONTROL BOARD | |
|
|
|
|
|
|
|
Page 17 |