White Rodgers PS9 Up service manual Section I USER’S Information, Table of Contents, Safety

USER’S INFORMATION, MAINTENANCE AND SERVICE MANUAL

HIGH EFFICIENCY

TUBULAR HEAT EXCHANGER SERIES

MODELS: PS9*UP / FC9S*UP / FL9S*UP (Single Stage Upflow)

EFFICIENCY

RATING

CERTIFIED

ISO 9001

Certified Quality

Management System

TABLE OF CONTENTS

CONTACT INFORMATION	1	SERVICE AND MAINTENANCE MANUAL	.5
USER’S INFORMATION	1	SAFETY SECTION	.5
SAFETY	1	FURNACE MAINTENANCE SECTION	.5
INSTRUCTIONS FOR EXAMINING THE		SEQUENCE OF OPERATION	.5
FURNACE INSTALLATION	2	Continuous Blower	.5
HOW YOUR GAS FURNACE WORKS	3	Intermittent Blower - Cooling	.5
START-UP AND SHUTDOWN INSTRUCTIONS	3	Heating Cycle	.5
Read the Instructions Below Before Trying to Start the Furnace . .	3	Hot Surface Ignition System	.6
Operating Instructions:	3	TROUBLESHOOTING	.6
To Turn Off the Appliance:	3	FURNACE CONTROL DIAGNOSTICS	.6
FURNACE USER MAINTENANCE	3	DIAGNOSTIC FAULT CODE STORAGE AND RETRIEVAL	.7
Air Filters	4	REPLACEMENT PARTS LIST	.8
Replacing Filters	4	REPLACEMENT PART CONTACT INFORMATION	10
Blower Care	4	WIRING DIAGRAM	11
Motor Lubrication	5	LIMITED WARRANTY	12

CONTACT INFORMATION

•Go to website at www.york.com click on “contact”, then click on “contact form” and follow the instructions.

•Contact us by mail:

York International

Consumer Relations

5005 York Drive

Norman, OK 73069

The manufacturer recommends that the user read all sec- tions of this manual and keep the manual for future refer- ence.

FIRE OR EXPLOSION HAZARD - Failure to follow safety warnings exactly could result in serious injury, death, or property damage.

—Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.

—WHAT TO DO IF YOU SMELL GAS:

•Do not try to light any appliance.

•Do not touch any electrical switch; do not use any phone (included cell phone) in your building.

•Leave the building immediately.

•Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.

•If you cannot reach your gas supplier, call the fire department.

—Installation and service must be performed by a qualified installer, service agency or the gas sup- plier.

SECTION I: USER’S INFORMATION

SAFETY

1.The furnace area must be kept clear and free of combustible mate- rials, gasoline and other flammable vapors and liquids.

2.Insulating materials may be combustible. The furnace must be kept free and clear of insulating materials. The furnace area must be examined when installed in an attic or other insulated space or when insulation is added to be sure that the insulation material has been kept away from the furnace.

3.The furnace needs air for combustion in order to operate properly and safely. Do not block or obstruct air openings on the furnace, air openings to the area where the furnace is installed, or spaces around the furnace.

4.Follow the instructions exactly as shown on the OPERATING INSTRUCTION LABEL or the Start-up and Shutdown Instructions on Page 3 of this manual when lighting the furnace or turning the furnace off.

5.Should the gas supply fail to shut off or if overheating occurs, shut off the gas valve to the furnace before shutting off the electrical supply.

6.Do not use this furnace if any part has been under water. A flood- damaged furnace is extremely dangerous. Attempts to use the fur- nace can result in fire or explosion. A qualified service agency should be contacted to inspect the furnace and replace all gas controls, control system parts, electrical parts that have been wet or the furnace if deemed necessary.

269434-UUM-A-0407