TROUBLE- SHOOTING
Continued
WARNING
WARNING ICON | G 001 |
If you smell gas
•Shut off gas supply.
•Do not try to light any appliance.
•Do not touch any electrical switch; do not use any phone in your building.
•Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.
•If you cannot reach your gas supplier, call the fire department.
IMPORTANT: Operating heater where impurities in air exist may create odors. Cleaning supplies, paint, paint remover, cigarette smoke, cements and glues, new carpet or textiles, etc., create fumes. These fumes may mix with combustion air and create odors.
OBSERVED | POSSIBLE |
|
|
|
|
| ||
PROBLEM | CAUSE | REMEDY |
|
|
| |||
|
|
|
|
|
|
|
|
|
Heater produces a | 1. | Metal expanding while | 1. | This is common with |
|
|
| |
clicking/ticking noise |
| heating or contracting |
| most heaters. If noise is | ||||
just after burner is lit |
| while cooling |
| excessive, contact |
|
|
| |
or shut off |
|
|
| qualified service person | ||||
|
|
|
|
|
|
|
|
|
Heater produces | 1. | Heater burning vapors | 1. | Ventilate room. Stop |
|
|
| |
unwanted odors |
| from paint, hair spray, |
| using |
|
|
| |
|
|
| glues, etc. See IMPOR- |
| products while heater is | |||
|
|
| TANT statement above |
| running |
|
|
|
|
| 2. | Low fuel supply | 2. | Refill supply tank |
|
|
|
|
| 3. | Gas leak. See Warn- | 3. | Locate and correct | all | ||
|
|
| ing statement at |
| leaks (see Checking Gas | |||
|
|
| top of page |
| Connections, page 14) | |||
|
|
|
|
|
|
|
| |
Heater shuts off in | 1. | Not enough fresh air is | 1. | Open window and/or |
|
|
| |
use (ODS operates) |
| available |
| door for ventilation |
|
|
| |
|
| 2. | Low line pressure | 2. | Contact local propane | |||
|
|
|
|
| gas company |
|
|
|
|
| 3. | ODS/pilot is partially | 3. | Clean ODS/pilot (see |
|
|
|
|
|
| clogged |
| Cleaning and Mainte- | |||
|
|
|
|
| nance, page 20) |
|
|
|
|
|
|
|
|
|
| ||
Gas odor even when | 1. | Gas leak. See Warn- | 1. | Locate and correct | all | |||
control knob is in |
| ing statement at |
| leaks (see Checking Gas | ||||
OFF position |
| top of page |
| Connections, page 14) | ||||
|
| 2. | Control valve defective | 2. | Replace control valve | |||
|
|
|
|
|
|
|
| |
Gas odor during | 1. | Foreign matter be- | 1. | Take apart gas tubing |
|
|
| |
combustion |
| tween control valve |
| and remove foreign |
|
|
| |
|
|
| and burner |
| matter |
|
|
|
|
| 2. | Gas leak. See Warn- | 2. | Locate and correct | all | ||
|
|
| ing statement at |
| leaks (see Checking Gas | |||
|
|
| top of page |
| Connections, page 14) | |||
|
|
|
|
|
| |||
Moisture/condensation | 1. | Not enough combus- | 1. | Refer to Fresh Air for | ||||
noticed on windows |
| tion/ventilation air |
| Combustion and Venti- | ||||
|
|
|
|
| lation requirements |
|
|
|
|
|
|
|
| (page 5) | 23 | ||
|
|
|
|
|
|
|
|
|
101869