Desa and 30, 24 installation manual Installing Middle Log #2 CCL3930PTB/NTB Shown

Page 15

INSTALLATION

Installing Logs (Cont.)

15

INSTALLATION

Continued

2.Place the base of the middle log (#2) in the U-shaped slots of the grate base. The cutout on the right of the middle log should fit over the burner (see Figure 25). Make sure the front of the middle log is resting on the tabs of the grate base.

3.Locate pins on the bottom of back log (#3). Slide these pins into the holes in the grate base behind the burner (see Figure 26).

4.Locate holes on the bottom of crossover log (#4). Slide front hole onto the left pin (CCL3924PTA/NTA or CCL3930PTB/ NTB) or middle pin (CCL3018PA/NA or CCL3018PTA/NTA) on the middle log (#2) and the pin on the back log (#3). See Figure 27 for placement.

5.For CCL3924PTA/NTA and CCL3930PTB/NTB Only: Locate pin and hole on the bottom of crossover log (#5). Slide the pin into the hole located in crossover log (#4). Slide the hole onto the pin on front log (#1). See Figure 28.

For CCL3018PA/NA and CCL3018PTA/NTA Only: Locate holes on the bottom of crossover log (#5). Slide the holes over the left pins on middle log (#2) and front log (#1). See Figure 29.

Middle Log (#2)

Burner

Tab	U-Shaped Slot

Figure 25 - Installing Middle Log #2 (CCL3930PTB/NTB Shown)

Pins

Rear Log (#3)

Hole in Grate

Base

Burner

Pins	Crossover Log (#4)

Middle Log

(#2)Back

Log (#3)

Figure 27 - Installing Crossover Log #4 (CCL3930PTB/NTB Shown)

Crossover Log (#5)

Crossover Log (#4)

Front Log (#1)

Figure 28 - Installing Crossover Log #5 (CCL3930PTB/NTB Shown)

Crossover

Log (#5)

Middle Log (#2)

Crossover

Log (#4)

Front Log (#1)

Figure 29 - Installing Crossover Log #5 (CCL3018PA/NA and

CCL3018PTA/NTA Only)

Figure 26 - Installing Rear Log #3 (CCL3930PTB/NTB Shown)

For morevisit www..com

111160-01A

Image 15

Contents CRL3124P/N What to do if YOU Smell GAS18, 24, and 30 Variable CRL2718P/NSafety Information Table of ContentsProduct Identification Product Features AIR for Combustion and Ventilation Local CodesUnpacking Determining FRESH-AIR Flow for Heater Location Confined and Unconfined SpaceDetermining if You Have a Confined or Uncon- fined Space Ventilation AIR Ventilation Air From Inside BuildingVentilation Air From Outdoors Check GAS Type InstallationMinimum Noncombustible Material Clearances If Using MantelDetermining Minimum Mantel Clearance Determining Minimum Mantel Clearance When Using a HoodMantel Clearances Floor ClearancesInstalling Damper Clamp Accessory for Vented Operation Installing Heater Base AssemblyInstallation Items Needed Attaching Flexible Gas Hose to Heater Gas Regulator Connecting to GAS SupplyChecking GAS Connections Pressure Testing Gas Supply Piping systemPressure Testing Heater Gas Connections Installing LogsInstalling Back Log #1 Installing Middle Log #2 CCL3930PTB/NTB Shown Single Burner Seasonal Oak Models CRL2718P/N, CRL2718P/N Installing Crossover Log #6 CCL3930PTB/NTB ShownLighting Instructions Operating HeaterShutting Off Heater Variable Control OperationTo Turn OFF GAS To ApplianceInstructions Manual Lighting ProcedurePilot Flame Pattern Inspecting BurnersTo Turn OFF GAS To Appliance Thermostat Control OperationMain Burner Cleaning MaintenanceCleaning Burner Injector Holder and Pilot AIR Inlet Hole Burner Primary AIR HolesObserved Problem Possible Cause Remedy TroubleshootingMaintenance, Gas leak. See Warning statement For Masonry and Factory-built Metal Fireplace Optional Positioning of Thermostat Sensing BulbTechnical Service Replacement PartsAccessories Service HintsSingle Burner Seasonal OAK Models SpecificationsDual Burner Smoky Mountain OAK Models Dual Burner Biltmore Split OAK ModelsIllustrated Parts Breakdown Variable MANUALLY-CONTROLLED Biltmore Split OAK Models Parts ListModels CGD3018PT, CGD3018NT, CGD3924PT and CGD3924NT THERMOSTATICALLY-CONTROLLED Smoky Mountain OAK Models Models CCL3018PTA and CCL3018NTA KEY Part Number CCL3018PTA CCL3018NTA Description QTY THERMOSTATICALLY-CONTROLLED Biltmore Split OAK ModelsModels CCL3924PTA, CCL3924NTA, CCL3930PTB and CCL3930NTB Parts List CRL3124P and CRL3124N Variable Manually Controlled Seasonal OAKDescription QTY Variable MANUALLY-CONTROLLED Seasonal OAK ModelsParts Central Owners Registration Form Postage Required 111160-01A Keep this Warranty Warranty Information