Viking VMOC205SS Door Disassembly, Door Adjustment, After adjustment, make sure of the following

Page 36

DMOC205SS

VMOC205SS

7.Make sure the door is parallel with oven face lines (left and upper side lines) and door latch heads pass through latch holes correctly.

8.Insert the lower oven hinge into oven cavity bottom flange and then engaged the door hinge pin. Then secure the lower oven hinge firmly with tree (3) mounting screws.

Note: After any service to the door;

(A)Make sure that door sensing switch and secondary interlock switch are operating properly. (Refer to chapter "Test Procedures".).

(B)An approved microwave survey meter should be used to assure compliance with proper microwave radiation emission limitation standards.

DOOR ADJUSTMENT

The door can be adjusted by keeping screws of each hinge loose.

After adjustment, make sure of the following :

1.Door latch heads smoothly catch latch hook through latch holes and that latch head goes through center of latch hole.

2.Deviation of door alignment from horizontal line of cavity face plate is to be less than 1.0mm.

3.Door is positioned with its face pressed toward cavity face plate.

4.Re-install outer case and check for microwave leakage around door with an approved microwave survey meter. (Refer to Microwave Measurement Procedure.)

Note: The door on a microwave oven is designed to act as an electronic seal preventing the leakage of microwave energy from oven cavity during cook

cycle. This function does not require that door be airtight, moisture (condensation)-tight or light-tight. Therefore, occasional appearance of moisture, light or sensing of gentle warm air movement around oven door is not abnormal and do not of themselves indicate a leakage of microwave energy from oven cavity. If such were the case, your oven could not be equipped with a vent, the very purpose of which is to exhaust the vapor-laden air from the oven cavity.

UPPER OVEN HINGE

RE-INSTALL

DOOR ASSEMBLY

LATCH

HEADS

LOWER OVEN HINGE

RE-INSTALL

Figure C-5. Door Replacement and adjustment

DOOR DISASSEMBLY

Remove door assembly, refer to "Door Replacement". Replacement of door components are as follows:

1.Place door assembly on a soft cloth with latches facing up.

Note: As the engaging part of choke cover and door panel are provided at several places, do not force any particular part.

2. Insert an putty knife (thickness of about 0.5mm) into the

gap between the choke cover and corner portion of door

2 LIFT UP

PUTTY KNIFE

1 BENT

CHOKE COVER

Door Bent

Panel

Upper

INSIDE Choke

cover

Lower

 

panel as shown Figure C-6 to free engaging parts.

3.

Lift up choke cover.

4.

Now choke cover is free from door panel.

FRONT

Figure C-6. Door Disassembly

34

Page 35 Page 37
Image 36
Page 35 Page 37
Contents Table of Contents Models DMOC205SS VMOC205SSBefore Servicing DMOC205SS VMOC205SS When the testing is completed Before ServicingMicrowave Measurement Procedure Canada Leakage test with enclosure installedRequirements Leakage test without enclosureMicrowave Measurement Procedure USA Leakage testIf provided, Vent Hood, Fan assembly, Cooling Fan Motor Viking Range CorporationMicrowave Ovens DMOC205SS VMOC205SS Foreword Specification DescriptionHigh MIX. Roast Oven Diagram VMOC205SSPower Level P-0 to P-90 Cooking OperationDescription of Operating Sequence OFF ConditionConvection Cooking Condition Automatic MIX Cooking ConditionSensor Cooking Condition Preheating ConditionFire Sensing Feature Microwave Mode Compu Defrost CookingCompu BROIL/ Compu ROAST/ Compu Bake Cooking SequenceSchematic Diagram Figure O-1. Oven Schematic-OFF ConditionFigure O-3. Oven Schematic-Automatic Mix Cooking Condition Description and Function of Components Troubleshooting Guide Damper OPEN-CLOSE MechanismMicrowave Cooking Damper OperationTest Procedure ProblemPower Transformer Test High Voltage Rectifier TestHigh Voltage Capacitor Test Test Procedures Letter Component Test Primary Interlock Switch and Third Door Switch TestMonitor Switch Secondary Interlock System TestDamper Switch Test Checking Temperature in the Convection ModeHeating Element Test Thermistor TestTouch Control Panel Assembly Test Noise Filter TestTest Procedures Letter Component Test KEY Unit Test Weight 1ST Stage 2ND Stage 3RD Stage 4TH Stage Level TimeRelay Test Compu Defrost TestSteps Occurrence Cause or Correction AH Sensor TestChecking the initial sensor cooking condition Water load cooking testTesting Method for AH Sensor AND/OR Control Unit Checking Control UnitTouch Control Panel Assembly Description of LSIThermistor LSIIXA103DRTemperature measurement input Oven Thermistor Digit selection signalConvection motor driving signal Cooling fan motor driving signalTOR Segment data signals Segment data signalKey strobe signal Absolute Humidity Sensor Circuit Structure of Absolute Humidity SensorServicing Component Replacement and Adjustment Procedure Power Transformer RemovalOuter Case Removal Magnetron RemovalHigh Voltage Rectifier Assembly Removal Positive Lock Connector NO-CASE Type RemovalDamper Assembly Removal High Voltage Capacitor RemovalOven Lamp and Lamp Socket Removal FAN Motor RemovalThermistor Removal Heating Element RemovalPower Supply Cord Replacement Control Panel Assembly and Control Unit RemovalControl Unit and KEY Unit Door Replacement and Adjustment AdjustmentAfter adjustment, check the following RemovalDoor Disassembly Door AdjustmentAfter adjustment, make sure of the following Microwave Measurement Procedure Preparation For TestingLeakage test Leakage Test with Enclosure Installed RequirementFigure S-1. Pictorial Diagram SFigureControl Panel DIP Parts List Electrical PartsCabinet Parts Control Panel PartsDoor Parts MiscellaneousScrews Nuts and Washers LX-NZ0029YBE0 Oven and Cabinet Parts Control Panel Parts Door Parts Packing and Accessories DMOC205SS VMOC205SS Copyright 2004 by Viking

VMOC205SS, DMOC205SS specifications

The Viking DMOC205SS and VMOC205SS are two state-of-the-art microwave ovens that redefine cooking convenience and efficiency. Designed for modern kitchens, these appliances come equipped with a range of features and technologies that enhance their usability and performance.

One of the most notable aspects of the Viking DMOC205SS and VMOC205SS is their powerful cooking capabilities. Both models utilize an advanced cooking system that ensures even heat distribution, resulting in perfectly cooked meals every time. With a robust wattage of up to 1,200 watts, these microwaves can quickly and efficiently prepare a wide variety of dishes.

The DMOC205SS features a spacious interior, offering 2.1 cubic feet of cooking space, making it ideal for larger families or those who frequently entertain guests. The VMOC205SS variant also shares a similar capacity but comes with additional features tailored for versatility. The interior design of both models includes a stainless steel finish that not only enhances durability but also adds a touch of elegance to any kitchen.

Functionality is at the forefront of the Viking DMOC205SS and VMOC205SS. Both models are equipped with multiple cooking modes, including microwave, convection, and grilling options. This multi-functional capability allows users to seamlessly switch between cooking methods, ensuring optimal results for various recipes. The intuitive control panel features easy-to-read buttons and a digital display, making it user-friendly for all cooking levels.

In terms of technology, these Viking microwaves incorporate sensor cooking, which automatically detects the moisture and temperature of food, adjusting cooking times accordingly. This feature not only prevents overcooking but also ensures consistently delicious results. The models also come with pre-programmed cooking settings for popular dishes, making meal preparation simpler and quicker.

Energy efficiency is another critical aspect of the Viking DMOC205SS and VMOC205SS. Both models are designed to minimize energy consumption while maximizing performance, which is beneficial for both the environment and the homeowner’s energy bills.

Safety features are embedded within the design of these microwaves. They include a child lock function to prevent accidental use, as well as a timer that ensures food is cooked for the precise amount of time needed.

In summary, the Viking DMOC205SS and VMOC205SS are exceptional microwave ovens that combine advanced technology, practical features, and stylish design. Their powerful cooking capabilities, user-friendly controls, and energy-efficient operation make them a perfect addition to any modern kitchen. These appliances empower users to explore a wide range of cooking possibilities, bringing convenience and quality to meal preparation.
Top Page Image Contents