Middleby Marshall PS640E III. Ventilation System, Requirements, Recommendations

Page 12

III. VENTILATION SYSTEM

IMPORTANT

Where national or local codes re- quire the installation of fire sup- pression equipment or other supplementary equipment, DO NOT mount the

equipment directly to the oven.

MOUNTING SUCH EQUIPMENT ON

THE OVEN MAY:

•VOID AGENCY CERTIFICATIONS

•RESTRICT SERVICE ACCESS

•LEAD TO INCREASED SERVICE EXPENSES FOR THE OWNER

A.Requirements

A mechanically driven ventilation system is STRONGLY RECOMMENDED for electric oven installations.

PROPER VENTILATION OF THE OVEN IS THE RESPONSI- BILITY OF THE OWNER.

B. Recommendations

NOTE THAT THE HOOD DIMENSIONS SHOWN IN FIGURE 2 - 5 ARE RECOMMENDATIONS ONLY . LOCAL, NATIONAL AND INTERNATIONAL CODES MUST BE FOLLOWED WHEN INSTALLING THE VENTILATION SYSTEM. ANY APPLICABLE CODES SUPERSEDE THE RECOMMENDATIONS SHOWN IN THIS MANUAL.

The rate of air flow exhausted through the ventilation system may vary depending on the oven configuration and hood design. Consult the hood manufacturer or ventilation engineer for these specifications.

To avoid a negative pressure condition in the kitchen area, return air must be brought back to replenish the air that was exhausted. A negative pressure in the kitchen can cause heat- related problems to the oven components as if there were no ventilation at all. The best method of supplying return air is through the heating, ventilation and air conditioning (HVAC) system. Through the HVAC system, the air can be tempera- ture-controlled for summer and winter. Return air can also be brought in directly from outside the building, but detrimental effects can result from extreme seasonal hot and cold tempera- tures from the outdoors.

NOTE: Return air from the mechanically driven system must not blow at the opening of the baking chamber. Poor oven baking performance will result.

C. Other ventilation concerns

•Special locations, conditions, or problems may require the services of a ventilation engineer or specialist.

•Inadequate ventilation can inhibit oven performance.

•It is recommended that the ventilation system and duct work be checked at prevailing intervals as specified by the hood manufacturer and/or HVAC engineer or specialist.

Figure 2-5. Ventilation System

18″ (458mm)

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

minimum

2″ (51mm)

8″ (203mm)

 

 

 

 

 

 

 

 

 

3″ (76mm)

(Typical - both

 

 

 

 

 

 

 

 

 

ends of oven)

 

minimum

minimum

 

 

 

 

 

 

 

 

 

minimum

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

8

Page 11 Page 13
Image 12
Page 11 Page 13
Contents Owners Operating and Installation Manual Retain this Manual for Future Reference Middleby Marshall Table of Contents Description Not ShownDimensions General SpecificationsRecommended Minimum Clearances Installation Parts List for Series PS640 Electric Oven Installation KIT Kit″ Legs Casters& Top Casters & Top Kit Model PS640 Single Oven Option Base with Legs and Top Model PS640 Double Oven Option Base with Legs and Top Model PS640 Triple Oven Option Base with Outriggers and Top III. Ventilation System RequirementsRecommendations Other ventilation concernsIV. Assembly Top Panel and Base Pad AssemblyRestraint Cable Installation StackingConveyor Installation Do not Overtighten the Conveyor BeltResetting Direction Jumper Switching Photo DetectorFinal Assembly Conveyor Belt ReversalIV. Electric Supply for Electrically Heated Ovens 18. Utility Connection Locations forDo not USE Conduit for Ground Connection Electric Supply to be Provided by CustomerLocation and Description of Controls Normal Operation STEP-BY-STEP Main ScreenDaily Startup Procedure Daily Shutdown ProcedureOven Temperature/Set Point/Indicator Screen Quick Reference Touch Screen Controller Main ScreenIII. Quick Reference Troubleshooting Maintenance Maintenance DailyII. Maintenance Monthly Top Row Bottom RowIII. Maintenance Every 3 Months Split Belt Disassembly and CleaningIV. Maintenance Every 6 Months Blower BeltKey Spare Parts Problem Oven does not Heat ProblemWiring Diagram 60231 Rev. A4

PS640E specifications

The Middleby Marshall PS640E is a state-of-the-art conveyor oven designed to meet the demands of high-volume food production with efficiency and precision. This innovative oven is widely used in pizzerias, restaurants, and various commercial kitchens, renowned for its ability to deliver consistent and high-quality food results.

One of the main features of the PS640E is its energy-efficient design. Utilizing advanced energy management technology, this oven minimizes energy consumption while maximizing cooking performance. The oven is equipped with a high-performance jet plate system that provides even heat distribution, ensuring that every dish is cooked uniformly. This technology substantially reduces cooking times, allowing operators to serve meals faster without compromising quality.

The PS640E also incorporates advanced temperature controls and an intuitive digital interface, which enable precise temperature adjustments throughout the cooking process. This feature is crucial for achieving optimal results, especially when working with a variety of food items that may require different cooking conditions. The digital controls allow for easy programmability, enabling chefs to create custom cooking profiles tailored to their specific menu items.

Another standout characteristic of the PS640E is its dual belt system. This innovative feature maximizes throughput by allowing different cooking temperatures on each belt, facilitating the preparation of diverse menu items simultaneously. This is especially beneficial in busy kitchen environments where efficiency and speed are crucial.

The oven's robust construction ensures durability and reliability under heavy use, making it a trusted choice for commercial operators. Its stainless-steel exterior not only enhances its aesthetic appeal but also makes it easy to clean and maintain. Furthermore, the PS640E has been designed with ergonomics in mind, promoting ease of use for kitchen staff.

In addition to its core functionalities, the Middleby Marshall PS640E supports a variety of cooking applications, making it a versatile addition to any kitchen. From pizzas and baked goods to roasted meats and vegetables, this oven excels in a wide array of culinary tasks, helping operators diversify their menu offerings.

In conclusion, the Middleby Marshall PS640E stands out in the crowded marketplace of commercial ovens due to its combination of energy efficiency, advanced cooking technologies, and versatile applications. Its robust design, precise controls, and user-friendly interface make it an indispensable tool for chefs and kitchen operators striving for excellence in food preparation.
Top Page Image Contents