Maytag MDB6600AW, MDBH950AW, MDB9600AW, MDBL540AW Wax Motor Check, Detergent / Rinse Aid Dispenser

Page 9

Electrical Equipment & Testing

for protection against shock hazard and should be plugged directly into a properly grounded and polarized receptacle.

It is the responsibility of the person installing the appliance to assure it is adequately grounded and polarized at the point of installation, taking into consideration local conditions and requirements. In cases where only a two (2) prong receptacle is available, it is the personal responsibility of the consumer to have it replaced with a properly grounded three (3) prong receptacle. All grounding and wiring should be done in accordance with National, State, and Local codes. DO

NOT USE AN ADAPTER PLUG WITH THIS APPLIANCE.

ELECTRICAL TESTS

Wax Motor Check

Detergent / Rinse Aid Dispenser

A single Wax Motor is used to activate both the release of the Detergent Cup Cover and the rinse aid from the reservoir.

To check the operation of the Wax Motor, removal from the Dispenser Retainer or Inner Door is not necessary. First, snap the Detergent Cup Door shut. Then, connect a Power Test Cord across the two terminals of the Wax Motor. Plug the Power Test Cord into a 120 VAC receptacle. The plunger in the center of the Wax Motor should "push out" and actuate the Dispenser in approximately 45-60 seconds. Remove voltage to the Wax Motor and allow the plunger to retract into the Wax Motor. Apply voltage to the Wax Motor again and observe for proper lifting of the rinse aid plunger.

!WARNING

To avoid risk of personal injury or death due to electrical shock:

•Disconnect electrical power to dishwasher before servicing.

•Always plug test cord into a properly grounded receptacle.

•Always make connection to components before plugging test cord into receptacle.

WATER VALVE TEST

The Water Valve may be checked without removing it from the Dishwasher.

To check the Water Valve for operation, hook up the test cord as follows:

©2002 Maytag Appliance Sales Company

16021814 Rev. 0

2-9

Page 8 Page 10
Image 9
Page 8 Page 10
Contents Jetclean Dishwashers ServiceImportant Notices for Consumers and Servicers Recognize Safety Symbols, Words, and LabelsCustomer Service Support Center Important InformationTable of Contents General Precautions and Warnings Important Safety InformationGeneral Information Related PublicationsPrecaución REV Electrical Test Equipment Electrical Equipment & TestingAppliance Test Meter Digital Test MeterGrounding and Polarity Motor Test CordClamp-On Ammeter Use of Ammeter on dishwasherDetergent / Rinse Aid Dispenser Wax Motor CheckWax Motor Check- Vent Cycles Cycles & OptionsOption Description Display Description ENN-AIR MDBH970 Electrical-Mechanical Troubleshooting Will Not FillOverflows Will Not Drain Poor WashabilityContinues To Drain Poor DryingWater Leaks Electrical Mechanical TroubleshootingNoise Will Not Start Or ProgramWill Not Wash Field Service TestWill Not Dry Manual Function TestService and Disassembly Procedures Removal Disconnect power to the machineFront Support and Toe Panel Removal Checking Operation Disconnect power to the machine Inner Door PanelDetergent / Rinse Dispenser Mechanism and Reservoir Wire Cover Wax Motor Detergent / Rinse DispenserVent Switch Removal Disconnect power to the machine Door Latch & Switch Holder AssemblyControl Panel PC BoardReplacement Outer DoorRemoval Door Hinge and Support Door SpringTop Wash Arm Door Spring and Component Replacement Over Pressure FilterLower Wash Arm Manifold Docking StationFloat To Check Float Switch Disconnect power to the machineTo Check Heating Element Disconnect power to the machine Heating ElementWattage Checks Water Valve ThermostatsAir Water Inlet Checking Valve OperationUpper Rack Removal Tub WheelsTurbidity Sensor Drain Pump Wash Motor AssemblyService and Disassembly Procedures AppendixA Built-In Dishwasher Built-In Dishwasher 16021814 Rev Refer to local plumbing codes / Consulte los códigos locales 13B Black to Black L1 Negro CON Negro L1 Start On some models Appendix B User Do not tamper with controls Important Safety InstructionsLoading With the Stack-Rack select models BackModels flat in the back, left corner pro Side. With the shelf down, two levelsHinged Be sure that thin, notSharp and p o i n t e d Items Your loadHard 10-12 gpg Normal SoilControls AT a Glance Controls AT a Glance Special Care Items Before YOU Call for Service Indicator Lights Flashing Dishwasher Warranty Appendix C Operating Tips Important Safety Instructions Loading Loading Loading Dishwashing essentials Options Controls at a glance Special care items Before you call Glasses Are Cloudy/Spotted To receive warranty service Appendix D Pages Dishwasher MDB-4Important Safety Instructions Scrape off tomato-based food soils see LoadingRack For best cleaning results, prevent itemsDown to NestingUtility Basket for Lower Rack will come to a stop when it is in positionHot water Short cycle for light food soils. Water usage is 6 gallons Full load. Controls odors gallons16021814 Rev Controls at a glance To cancel a running cycle, press the START/Cancel padMaterial Dishwasher Safe? Special Informatiion Special care itemsDishwasher Will Not Fill Indicator Lights FlashingDishwasher Will Not Drain/Water In Tub Bottom Dishwasher Adds Water at END of CycleFood Soil Remains on Dishes Glasses Are Cloudy/SpottedDishware is Chipped Dishwasher Door Will Not CloseLimited Second Year Warranty Full One Year WarrantyLimited Third Through Fifth Year Warranty Full Twenty-Year Warranty

MDB5600AW, MDB6600AW, MDB7600AW, JDB4000AW, MDB8600AW specifications

The Maytag MDB7600AW, MDB6600AW, MDB8600AW, MDBF550AW, and MDBF750AW dishwashers combine power, efficiency, and innovation, designed to tackle tough stains while providing user-friendly features. Maytag is known for its strong performance, making these models popular choices for homeowners seeking reliable dishwashing solutions.

Starting with their cleaning capabilities, these dishwashers are equipped with the PowerBlast Cycle, which utilizes high-pressure jets to remove stubborn food particles, ensuring that dishes come out spotless. The dedicated scrubbers can handle baked-on messes and pet food debris, making them ideal for busy households.

Energy efficiency is another strong suit of these models. Many of the dishwashers feature the Energy Star certification, indicating they consume less water and electricity without compromising performance. This not only helps reduce utility bills but also contributes positively to environmental sustainability.

The capacity of these models is thoughtfully designed to accommodate a wide variety of dishware. With adjustable racks and ample space, users can easily fit pots, pans, and large platters. The MDB8600AW and MDB7600AW offer a third rack for extra loading flexibility, allowing for more efficient use of space.

In terms of reliability, Maytag emphasizes durability with their stainless steel tub, which resists stains and provides long-lasting performance. Furthermore, these dishwashers come with a 10-year limited parts warranty, giving users peace of mind regarding any potential issues.

Technologically, the models are equipped with smart features like a soil sensor that detects how dirty the dishes are and adjusts the wash cycle accordingly. The Quiet Series technology ensures that operations remain quiet, allowing for a peaceful home environment while the dishwasher is running.

The exterior of these models is sleek and modern, available in various finishes to match different kitchen decors. With intuitive controls and various wash cycle options, users can select the ideal setting for their dishwashing needs, from quick washes to heavy-duty cycles.

In summary, the Maytag MDB7600AW, MDB6600AW, MDB8600AW, MDBF550AW, and MDBF750AW dishwashers are designed for consumers who value efficiency and powerful cleaning. With high-performance features, energy savings, capacity for large loads, durability, and advanced technology, these dishwashers are a strong choice for any kitchen. Whether tackling everyday dishes or more challenging messes, Maytag continues to deliver exceptional cleaning results.
Top Page Image Contents