Manitowoc Ice STH003 manual Liquid Line Thermistor

Page 6

HOT GAS VALVE		52
BIN THERMOSTAT		55
ICE PRODUCTION CHECK		57
ADJUSTING CUBE WEIGHT		58
LIQUID LINE THERMISTOR		59
TOTAL SYSTEM REFRIGERATION
CHARGE		61
COMPONENT SPECIFICATIONS AND CHECK
PROCEDURES		62
MAIN FUSE		62
COMPRESSOR ELECTRICAL
DIAGNOSTICS		63
DIAGNOSING START COMPONENTS: ....		65
CYCLE TIMES, 24 HR ICE PRODUCTION AND
REFRIGERANT PRESSURE CHARTS		66
REFRIGERANT DEFINITIONS		68
REFRIGERANT RE-USE POLICY		69
SYSTEM CONTAMINATION CLEANUP ...		75
SEVERE SYSTEM CONTAMINATION
CLEANUP PROCEDURE	ERROR!
BOOKMARK NOT DEFINED.
REPLACING PRESSURE CONTROLS
WITHOUT REMOVING REFRIGERANT
CHARGE		80
BRAZING PROCEDURES FOR DANFOSS
SOLENOID VALVES		82
FILTER-DRIERS		84
CONTROL BOARD		85
WIRING DIAGRAMS		88
TUBING SCHEMATIC		87

6

Image 6

Contents CM050 CM Model Ice Machines Safety Notices Procedural Notices Read These Before Proceeding Personal Injury PotentialPotential Personal Injury Situation Table of Contents Liquid Line Thermistor CMS050A004 Model NumbersAccessories Legs Manitowoc ICE Machine Cleaner and SanitizerDrain Pump MODEL/SERIAL Number Location Owner Warranty Registration Card GeneralPage Manitowoc ICE, INC Installation Location of ICE MachineICE Machine Heat of Rejection Heat of Rejection Air Conditioning** PeakLeveling the ICE Machine Levelers LegsWater SERVICE/DRAINS Water Supply Water Inlet LinesDrain Connections Drain Pump Water Supply and Drain Line SIZING/CONNECTIONSMinimum Circuit Ampacity Electrical SpecificationsElectrical Requirements Voltage Gfci RequirementsComponent Identification Water Pump Evaporator Shutter Assembly Clean Green BIN Thermostat AdjustmentPower Button Green Operational ChecksSafety Timers Cleaning the Condenser ICE Machine InspectionAIR-COOLED Condenser Interior Cleaning and Sanitizing Interior Cleaning and Sanitizing General Place CLEANING/SANITIZING ProcedurePage Cleaning Procedure Page Page Removal of Parts for Cleaning and Sanitizing TOP Cover Water Shutters ICE Chute Sump Drain Overflow Tube Water Trough Spray BAR, Water Pump and Hose Spray BAR Disassembly Removal from SERVICE/LONG Term STORAGE/WINTERIZATION General SELF-CONTAINED AIR-COOLED ICE MachinesHarvest Refrigeration System Start-UpFreeze Automatic Shut-OffEnergized Parts Chart SELF-CONTAINED ICE Machines SequenceTroubleshooting Diagnosing AN ICE Machine That will not RUNPage ICE Machine will not Harvest ICE Quality is Poor Cubes are SHALLOW, Incomplete or White Freeze Cycle is LONG, LOW ICE Production ICE Machine Runs & no ICE is Produced Freeze Harvest Cycle Psig Beginning Freeze Cycle Discharge Pressure LOW Checklist Analyzing Suction Pressure Procedure StepSuction Pressure High Checklist Problem Suction Pressure LOW Checklist ProblemDischarge Pressure HOT GAS Valve GeneralNormal Operation HOT GAS Valve Analysis Freeze cycle. If Specifications FunctionCheck Procedure No Ice on Ice on Bulb ResultFreeze Time Harvest Time Total Cycle Time Adjusting Finishing Time Additional finishing time checkLiquid Line Thermistor TEMPERATURE/RESISTANCE Chart SM50 Resistance ChartTotal System Refrigeration Charge Component Specifications Check Procedures Check Resistance OHM Values Compressor Electrical DiagnosticsSingle Phase Compressors Check Motor Windings to GroundCompressor Drawing Locked Rotor Compressor Drawing High AmpsCapacitor RelayPage Cycle Times Freeze Time + Harvest Time = Cycle Time Recycle RecoverNew Product Specifications ReclaimRefrigerant RE-USE Policy Page Refrigerant Recovery/Evacuation/Charging ConnectionsRecovery/Evacuation Charging Procedures Page System Contamination Cleanup General No symptoms or suspicion Normal Mild System Contamination Cleanup Procedure Severe System Contamination Cleanup Procedure Change the vacuum pump oilFollow normal evacuation procedures Page Using Pinch Off Tool FIG. a Pinching OFF TubingBrazing Procedures for Danfoss Solenoid Valves Do not disassemble valveMAX F 700C Liquid Line Filter Drier Control Board Wiring Diagrams Tubing Schematic Manitowoc Ice, Inc