Multiquip manual MVC-70H/HW Components Honda GX160K1QMX2 Engine

MVC-70H/HW — COMPONENTS (HONDA GX160K1QMX2 ENGINE)

Figure 4. Engine Controls & Components

INITIAL SERVICING

The engine (Figure 4) must be checked for proper lubrication and filled with fuel prior to operation. Refer to the manufacturer's engine manual for instructions and details of operation and servicing.

1. Fuel Filler Cap – Remove this cap to add unleaded gasoline to the fuel tank. Make sure cap is tightened securely. DO NOT over fill.

Danger - Flammable Fuel

Adding fuel to the tank should be done only when the engine is stopped and has had an opportunitytocooldown. Intheeventofafuel spill, DO NOT attempt to start the engine until the fuel residue has been completely wiped up, and the area surrounding the engine is dry.

2. Throttle Lever – Used to adjust engine RPM speed (lever advanced forward SLOW, lever back toward operator FAST).

3.	Engine ON/OFF Switch – ON position permits engine
	starting, OFF position stops engine operations.
4.	Recoil Starter (pull rope) – Manual-starting method. Pull
	the starter grip until resistance is felt, then pull briskly and
	smoothly.

5.	Fuel Valve Lever – OPEN to let fuel flow, CLOSE to stop
	the flow of fuel.
6.	Choke Lever – Used in the starting of a cold engine, or in
	cold weather conditions. The choke enriches the fuel
	mixture.
7.	Air Cleaner – Prevents dirt and other debris from entering
	the fuel system. Remove wing-nut on top of air filter
	cannister to gain access to filter element.
		Operating the engine without an
	NOTE	air filter, with a damaged air filter,
		or a filter in need of replacement
		will allow dirt to enter the engine,
		causing rapid engine wear.
8.	Spark Plug – Provides spark to the ignition system. Set
	spark plug gap to 0.6 - 0.7 mm (0.028 - 0.031 inch) for
	HONDA engine. Clean spark plug once a week.
9.	Muffler – Used to reduce noise and emissions.

Warning - Hot Surface

Enginecomponentscangenerateextremeheat. To prevent burns, DO NOT touch these areas while the engine is running or immediately after operating. NEVER operate the engine with the muffler removed.

10. Fuel Tank – Holds unleaded gasoline. For additional information refer to engine owner's manual.

MVC-70H/HW PLATE COMPACTOR — OPERATION & PARTS MANUAL — REV. #2 (11/02/05) — PAGE 15