Multiquip manual MVC-70H/HW Inspection, Before Starting, Engine Oil Check, Gasoline Check

Page 16

Before Starting

1.Read safety instructions at the beginning of manual.

2.Cleanthecompactor,removingdirtanddust.Particularly,the bottom of the plate, engine cooling air inlet, carburetor and air cleaner.

3.Check theair filterfor dirtand dust.If theair filterisdirty,blow through the air filter cartridge from the inside, moving a jet of dry compressed air up and down until all dust is removed. Otherwise replace air filter with a new one.

4.Check carburetor for external dirt and dust. Clean with dry compressedair.

5.Check fastening nuts and bolts for tightness. Loosened screws or bolts due to vibration, could lead to unexpected accident.

Engine Oil Check

1.To check the engine oil level, place the plate compactor on secure level ground with the engine stopped.

2.Remove the filler cap/dipstick from the engine oil filler hole (Figure 5) and wipe it clean.

Figure 5. Engine Oil Dipstick

3.Insertandremovethedipstickwithoutscrewingitintothefiller neck. Check the oil level shown on the dipstick.

4.If the oil level is low (Figure 6), fill to the edge of the oil filler hole with the recommended oil type (Table 4).

UPPER LIMIT

LOWER LIMIT

Figure 6. Engine Oil Dipstick

MVC-70H/HW — INSPECTION

The Oil Alert system will automatically stop the engine

NOTE

before the engine falls below safe

 

 

limits. Always be sure to check

 

the engine oil level prior to starting

 

the engine.

 

 

 

 

 

Table 4. Oil Type

 

 

 

 

Season

Temperature

Oil Type

 

 

 

Summer

25°C or Higher

SAE 10W-30

 

 

 

Spring/Fall

25°C~10°C

SAE 10W-30/20

 

 

 

Winter

0°C or Lower

SAE 10W-10

 

 

 

Gasoline Check

1.Remove the gasoline cap located on top of fuel tank.

2.Visuallyinspecttoseeiffuellevelislow. Iffuelislow,replenish with unleaded fuel.

Danger - Flammable Fuel

Motor fuels are highly flammable and can be dangerous if mishandled. DO NOT smoke while refueling. DO NOT attempt to refuel the compactor if the engine is hot! , running or in the dark.

3.When refueling, be sure to use a strainer for filtration. DO NOT top-off fuel. Wipe up any spilled fuel.

Vibrator Oil Check

1.Place the MVC-70H/HW plate compactor horizontally on a flatsurface.Makesurethecompactorislevelwhenchecking the oil in the vibrator assembly.

2.Check vibratoroillevelbyremoving theplug (vibrator oilgauge) as shown in Figure 7. The oil level should be up to the oil plug. If oil is required, replace using only SAE 10W-30 motor oil.

Figure 7.Vibrator Oil Plug

PAGE 16 — MVC-70H/HW PLATE COMPACTOR — OPERATION & PARTS MANUAL — REV. #2 (11/02/05)

Image 16
Contents Model MVC-70H/HW Proposition Page Table of Contents Best Deal! Order via Internet Dealers Only Parts Ordering ProceduresOrder via Fax Dealers Only MVC-70H/HW Specifications MVC-70H/WMVC-70H/HW Dimensions MVC-70H/HW Safety Message Alert Symbols MVC-70H/HW Safety Message Alert Symbols MVC-70H/HW Rules for Safe Operation MVC-70H/HW Rules for Safe Operation Loading and Unloading CraneMachine Safety Decals Operation and Safety DecalsDefinition of Plate Compactor Vibratory PlateFrequency/Speed EngineWater tube Counter weightsLiters of water, removable no tools required MVC-70H/HW Components Honda GX160K1QMX2 Engine MVC-70H/HW Inspection Before StartingEngine Oil Check Gasoline CheckBelt Check Belt HazardMVC-70H/HW Initial START-UP Fuel Valve LeverStopping the Engine OperationMVC-70H/HW Maintenance Inspection and Maintenance ServiceTablesDaily Service Engine Oil ReplacementReinstalling the V-belt Changing Vibrator OilChecking and Replacing the V-Belt and Clutch Replacing the V-beltMVC-70H/HW Preparation for Long -TERM Storage Compactor StorageMVC-70H/HW Troubleshooting Engine MVC-70H/HW Troubleshooting Engine MVC-70H/HW Troubleshooting Plate Compactor Plate Compactor TroubleshootingNO. Column Part NO. ColumnQTY. Column Remarks ColumnMVC-70H/HW Suggested Spare Parts To 3 UnitsMVC-70H/HW Name Plate and Decals Name Plate and DecalsWater Tank Nameplate and DecalsMQ/WATER Tank MVC-70H/HW Main Body ASSY. OLD Style Main Body ASSY. OLD StyleEarth Wire Shock Absorber D45-H41NUT M10 WASHER, Lock M10MVC-70H/HW Main Body ASSY. NEW Style Main Body ASSY. NEW StyleSpacer 20.2X25X9.4, Clutch KEYWASHER, Lock WASHER, FlatMVC-70H/HW -VIBRATOR Assy Vibrator AssyVibrating Case WASHER, Lock M14WASHER, Flat M14 Case COVER/PULLEYMVC-70H/HW Watertank Assy Water Tank AssyHook CAP, Water TankWasher 10.5X21X2 SUS Nylon NUT M10 SUSHonda GX160K1QMX2 Engine Cylinder Head Assy Cylinder Head AssyCLIP, Valve Guide GASKET, Cylinder HeadCOVER, Head TUBE, BreatherHonda GX160K1QMX2 Engine Cylinder Barrel Assy Cylinder Barrel AssyWEIGHT, Governor HOLDER, Governor WeightIncludes Items W Includes Items W/ #Honda GX160K1QMX2 Engine Crankcase Cover Assy Crankcase Cover AssyGASKET, Case Cover GASKET, OIL Filler CAPHonda GX160K1QMX2 Engine Crankshaft Assy Crankshaft AssyCrankshaft Q-TYPE Honda GX160K1QMX2 Engine PISTON/RINGS Assy PISTON/RINGS AssyBOLT, Connecting ROD Ring SET, Piston STDRing SET, Piston OS Piston STDHonda GX160K1QMX2 Engine Camshaft Assy Camshaft AssySPRING, Weight Return ROD, PushARM, Vlave Rocker LIFTER, ValveHonda GX160K1QMX2 Engine Recoil Starter Assy Recoil Starter AssySCREW, Setting REEL, Recoil StarterRATCHET, Starter GUIDE, RatchetHonda GX160K1QMX2 Engine FAN Cover Assy FAN Cover AssyCOVER, FAN *NH1* Black PLATE, Side OIL AlertCLIP, Harness ShroudHonda GX160K1QMX2 Engine Carburetor Assy Carburetor AssyPLATE, Lever Setting Gasket SETValve SET, Float Float SETHonda GX160K1QMX2 Engine AIR Cleaner Assy AIR Cleaner AssyAIR Cleaner Dual Assy GROMMET, AIR CleanerCOLLAR, AIR Cleaner Collar B, AIR CleanerHonda GX160K1QMX2 Engine Muffler Assy Muffler AssyPROTECTOR, Muffler CAP, MufflerARRESTER, Spark GASKET, MufflerHonda GX160K1QMX2 Engine Fueltank Assy Fuel Tank AssyJOINT, Fuel Tank TANK, Fuel *NH1* BlackGASKET, Fuel Filler CAP FILTER, FuelHonda GX160K1QMX2 Engine Flywheel Assy Flywheel AssyFAN, Cooling PULLEY, StarterFlywheel Flywheel LampHonda GX160K1QMX2 Engine Ignition Coil Assy Ignition Coil AssyWIRE, Stop Switch 370MM Coil ASSY., IgnitionHonda GX160K1QMX2 Engine Control Assy Control AssyHOLDER, Wire ARM, GovernorROD, Governor SPRING, GovernorNo Artwork Available Honda GX160K1QMX2 Engine Gasket KIT Assy Gasket KIT AssyHonda GX160K1QMX2 Engine Labels Assy Labels AssyMARK, Choke LABEL, CautionMARK, OIL Alert E Terms and Conditions of Sale Parts Page Heres HOW to GET Help