Craftsman 28035 Transaxle Gear Shift Lever NEU= Tral Adjustment, To Remove Wheel, Alignment

Page 25

TRANSAXLE GEAR SHIFT LEVER NEU= TRAL ADJUSTMENT

The transaxle should be in neutral when the

gear shift lever is in neutral (N) (lock gate)

position. The adjustment is preset at the factory; however, if adjustment is needed, proceed as follows:

1.Make sure transaxle is in neutral (N). NOTE: When the tractor rear wheels move

freely, the transaxle is in neutral.

2.Loosen adjustment bolt in front of the right rear wheel.

3.Position the gear shift lever in the neutral

(N)position.

4.Tighten adjustment bolt securely.

NOTE: If additional clearance is needed to get to adjustment bolt, move mower deck height to the lowest position.

GearshiftAdjustment Bolt Lever

Jtral

Lock Gate

TO REMOVE WHEEL

1.Block up axle securely.

2.Remove axle cover, retaining ring and washers to allow wheel removal (rear wheels have a square key-Do not lose).

3.Repair tire and reassemble.

NOTE: On rear wheels only: align grooves in rear wheel hub and axle. Insert square key.

4.Replace washers and snap retaining ring securely in axle groove.

5.Replace axle cover.

NOTE: To seal tire punctures and prevent

flat tires due to slow leaks, purchase and use tire sealant from Sears. Tire sealant also

prevents tire dry rot and corrosion.

Washers

Retaining

Rin(

Axle

Cover

Square

Key _

(Rear Wheel Only)

TO ADJUST STEERING WHEEL

ALIGNMENT

If steering wheel crossbars are not horizontal (left to right) when wheels are positioned straight forward, remove steering wheel and reassemble per instructions in the Assembly section of this manual.

FRONT WHEEL TOE-IN/CAMBER

Your new tractor front wheel toe-in and

camber is set at the factory and is normal. The front wheel toe-in and camber are not

adjustable. If damage has occurred to affect the factory set front wheel toe-in or camber, contact a qualified service center.

TO START ENGINE WITH WEAK BATTERY

,_,WARNING" Lead-acid batteries generate explosive gases. Keep sparks, flame and

smoking materialsawayfrom batteries. Always wear eye protection when around batteries.

If your battery is too weak to start the engine, it should be recharged. (See "BATTERY" in the

MAINTENANCE section of this manual).

If "jumper cables" are used for emergency starting, follow this procedure:

IMPORTANT: Your tractor is equipped with a 12 volt system. The other vehicle must also be a 12 volt system. Do not use your tractor battery to start other vehicles.

TO ATTACH JUMPER CABLES-

1.Connect one endoftheREDcabletothe

POSITIVE (+) terminal of each battery(A- B), taking care notto short against tractor chassis.

2.Connect one end of the BLACK cable to the NEGATIVE (-) terminal (C) of fully charged battery.

3.Connect the other end of the BLACK cable (D) to good chassis ground, away from fuel tank and battery.

TO REMOVE CABLES, REVERSE ORDER-

1.BLACK cable first from chassis and then from the fully charged battery.

2.RED cable last from both batteries.

Weak or

 

Fully

Dead

[---1 [--']

Charged

Battery

Battery

 

25

Image 25
Contents LAW Tracto Craftsman Full Warranty TWO Years on Riding Equipment General Operation Safe Handling of Gasoline ServiceSERVlCE GeneralRepair Protection Product Specifications411111 To Check Battery Tools Required for AssemblyBefore Removing Tractor from Skid To Remove Tractor from Carton Unpack CartonTo Assembly Bagger To Adjust SeatCheck Tire Pressure PaddleCheck for Proper Position of ALL Belts @@@@ Reverse Operation System ROS Know Your TractorStopping HOW to USE Your TractorEngine To SET Parking BrakeTo Stop Mower Blade To Operate MowerTo Transport Towing Carts and Other ATTACH- MentsTo Start Engine Before Starting the EngineCheck Engine OIL Level To Operate on HillsMulching Mowing Tips Mowing TipsTo Dump Bagger Lubrication Chart MaintenanceSchedule Tires Engine BatteryTo Change Engine OIL BeltsMuffler Engine Cooling SystemTo Remove Mower To Install MowerAttach Mower Side Suspension FRONT-TO-BACK Adjustm ENT Visual SIDE-TO-SIDE AdjustmentPrecision SIDE-TO-SIDE Adjustment To Level MowerTo Replace Mower Blade Drive Belt Belt InstallationBelt Removal To Replace Motion Drive BeltTo Adjust Steering Wheel Transaxle Gear Shift Lever NEU= Tral AdjustmentTo Remove Wheel AlignmentInterlocks and Relays Replacing BatteryEngine OIL Fuel SystemProblem Cause Correction Troubleshooting ChartCorrection Problem CauseLevel mower deck ProblemNeed More HELP? Only Ride UP and Down Hill Not Across Hill Degrees MAX Suggested Guide for Sighting Slopes for Safe OperationEspecificaciones del Producto Funcionamiento General IV. Remolque III, NinosOperaciones DE Servicio Generales Page LA REPARACI6N Especificacionesdel ProductoResponsabilidades DEL Cliente 411111 Para Remover EL Tractor DE LA Herramientas Necesarias Para EL MontajePara Montar EL Contenedor Remuevay desechesedelcintaCON Paleta Para Ajustar EL Brazo CompletoRevision DE LA Presion DE LAS Llantas DE Todas LAS Correas@@@@@ SU Tractor Familiaricese CON SU TractorPalanca DEL Levantamiento DEL Palanca DEL Freno DEParada Como Usar SU TractorFuncionamiento Atras Antes DE Hacer Arrancar EL Para Operar EN CerrosMotor Consejospara Segar Consejos Para Segar Y AcolcharMantenimiento Antes DE Cada USOLlantas TractorVeri Fiez Sistema Funci Onam Iento AT RA,S ROS Cuidado DE LA CuchillaMotor Lubricacion CorreasvPara CAM Biar Elaceite DEL Motor Filtro DEL AireLimpieza Limpiezadela RejilladeaireSilenciador Filtro DE Combustible EN LineaVicio O DE Hacer Ajustes CespedPara Desmontar LA Cortadora DE Instale LA SegadoraFije LA Pieza DE Union Anterior Fije LOS Brazos DE SuspensionAjuste DE Delante a ATR,S Regulacionvisualdeladoa LadoRegulacion DE LA Precision DE Lado Para Cambiar LA Cuchilla DEL Para Remover LAS Ruedas Regulaciondela Palancade VELOCI=Para Ajustar EL Alineamiento DEL Volante DE Direccion CONVERGENCIA/INCLINACION DE LAS Ruedas DelanterasMotor Reemplazarla BateriaPara Cambiar EL Fusible Otros TractorSistema DE Combustible Aceite DEL MotorCausa IDENTIFICACI6N DE ProblemasEl corte IdentificaciondeproblemasLas luz ces de Lanteras no funcio Page Cuesta Abajo Y no Atraviese EL Cerro Operacion Segura15GRADOS MAX SR/AP Your Home