TROUBLESHOOTmNG CHART:
See appropriate section in manuem urfless directed to Sears service center
CAUSECORRECTION
Poor grass1. Engine speed too slow. discharge
2.Travel speed too fast.
3.Wet grass.
4.Mower deck not level.
5.Low/uneven tire air pressure.
6.Worn, bent or loose blade.
7.Buildup of grass, leaves and trash under mower.
8.Mower drive belt worn.
9.Blades improperly installed.
10.Improper blades used.
11.Clogged mower deck vent holes from buildup of grass, leaves, and trash around mandrels.
1.Place throttle control in "FAST" position.
2.Shift to slower speed.
3.Allow grass to dry before
mowing.
4.Level mower deck.
5.Check tires for proper air pressure.
6.Replace/sharpen blade. Tighten blade bolt.
7.Clean underside of mower
housing.
8.Replace mower drive belt.
9.Reinstall blades sharp edge down.
10.Replace with blades listed in this manual.
11.Clean around mandrels to open vent holes.
iHeadiight(s) not working
i(if so equipped)
iBattery wiii not icharge
Loss of drive
1. | Switch | is "OFF". |
|
| 1. | Turn switch | "ON". |
|
| ||||||
2. | BuD(s) or lamp(s) burned out. | 2. | Replace | bulb(s) | or | lamp(s). | |||||||||
3. | Faulty | light | switch. |
| 3. | Check/replace |
| light | switch. | ||||||
4. | Loose | or damaged | wiring. | 4. | Check | wiring | and | connections. | |||||||
5. | Blown | fuse. |
|
|
|
| 5. | Replace | fuse. |
|
|
| |||
1. | Bad | battery | cell(s). |
| 1. | Replace | battery. |
|
|
| |||||
2. | Poor | cable | connections. | 2. | Check/clean | all | connections. | ||||||||
3. | Faulty | regulator |
|
| 3. | Replace | regulator. |
|
| ||||||
| (if so |
| equipped). |
|
|
|
|
|
|
|
|
|
| ||
4. | Faulty | alternator. |
|
| 4. | Replace | alternator. |
|
| ||||||
1. | Freewheel | control |
| in | 1. | Place | freewheel | control | in | ||||||
| "disengaged" |
| position. |
| "engaged" | position. |
|
| |||||||
2. | Motion | drive | belt | worn, | 2. | Replace | motion | drive | belt. | ||||||
| damaged, | or | broken. |
|
|
|
|
|
|
|
| ||||
3. | Air trapped | in | transmission | 3. | Purge | transmission. |
|
| |||||||
| during | shipment | or | servicing. |
|
|
|
|
|
|
|
| |||
Engine | "backfires" | , Engine throttle control | not set | , Move throttle control to | |||||
when | turning | at | "SLOW" | position | for | 30 | "SLOW" | position and | allow |
iengine | "OFF" | 30 | seconds | before | stopping | to idle | for 30 seconds | before | |
|
| engine. |
|
|
| stopping | engine. |
| |
32