....... i
TROU LESHOOTI G POINTS
PROBLEM | CAUSE | CORRECTION |
,\
Engine | continues | to | run | I. | Faulty | presence control system. | ||||||||
when | operator | leaves | seat |
|
|
|
|
|
|
|
| |||
with | attachment | eiutch |
|
|
|
|
|
|
|
| ||||
engaged |
|
|
|
|
|
|
|
|
|
|
|
| ||
Poor Cut - uneven |
|
| 1. | Worn, | bent | or loose | blade. | |||||||
|
|
|
|
|
|
| 2, | Mower | deck not ieveL |
| ||||
|
|
|
|
|
|
| 3. | Buitdup of grass, leaves, and trash under mower. | ||||||
|
|
|
|
|
|
| 4. | Bent blade | mandrel, |
| ||||
Mower | blades | wltl | not |
| t. | Obstruction | in clutch mechanism. | |||||||
rotate |
|
|
|
|
|
| 2. | Worn/damaged | mower | drive belt. | ||||
|
|
|
|
|
|
| 3. | Frozen | idlerpulley. |
|
| |||
|
|
|
|
|
|
| 4. | Frozen | blade mandrel, |
| ||||
Poor | grass | dIscharge |
| t. | Engine | speed too slow. |
| |||||||
|
|
|
|
|
|
| 2, Travel speed too fast. |
| ||||||
|
|
|
|
|
|
| 3. | Wet | grass, |
|
|
|
| |
|
|
|
|
|
|
| 4. | Mower deck not level. |
| |||||
|
|
|
|
|
|
| 5, | Low/uneven | tire air pressure. | |||||
|
|
|
|
|
|
| 6, | Worn, | bent | or loose | blade. | |||
|
|
|
|
|
|
| 7. Buildup of grass, leaves and trash under mower. | |||||||
|
|
|
|
|
|
| 8. | Mower drive belt worn. |
| |||||
|
|
|
|
|
|
| 9. | Blades | improperly installed. | |||||
|
|
|
|
|
|
| t0. | {mproperblades | used. |
| ||||
Headlight(s) not working | 1. | Switch | is "OFF". |
|
| |||||||||
(if so equipped) |
|
| 2. | Bulb(s) | burned | out. |
|
| ||||||
|
|
|
|
|
|
| 3. | Faulty | light | switch, |
|
| ||
|
|
|
|
|
|
| 4. | Loose | or damaged | wiring, | ||||
|
|
|
|
|
|
| 5. | Blown | fuse. |
|
|
|
| |
Battery | will | not | charge |
| 1. | Bad | battery'cell(s). |
|
| |||||
|
|
|
|
|
|
| 2. | Poor | cabte | connections. | ||||
|
|
|
|
|
|
| 3. | Faulty | regulator | (if so equipped), | ||||
|
|
|
|
|
|
| 4. | Faulty | alternator. |
|
| |||
Tractor | "creeps" | with |
| 1. | Motion | control | lever | is out of adjustment. | ||||||
motion | control | lever in |
|
|
|
|
|
|
|
| ||||
"neutra!" | position |
|
|
|
|
|
|
|
|
|
| |||
1.Check wiring, switches and connections. If not corrected, contact Sears Service Department,
i.Replace blade, Tighten blade bolt.
2.Level mower deck,
3.Clean underside of mower housing.
4.Replace blade mandrel,
t.Remove obstruction.
2.Replace mower ddve belt, 3, Replace idler pulley.
4, Replace blade mandrel,
1.Place throttle control in "FAST" position.
2.Shift to slower speed.
3, Allow grass to dry before mowing.
4.Level mower deck.
5.Check tires for proper air pressure,
6, Repiaceisharpen blade. Tighten blade bolt. 7, Clean underside of mower housing.
8, Replace mower drive belt.
9.Reinstall blades sharp edge down.
t0. Replace with blades listed in this manual
1.Turn switch "ON". 2, Replace bulb(s).
3.Check/replace light switch,
4.Check widng and connections.
5.Replace fuse.
1.Replace battery,
2.Check/clean all connections.
3.Replace regulator.
4.Replace alternator.
1.Adjust motion control lever.
27