Sears 917.25559 manual Ass Ly, Checkmst

Page 9

ASS LY

iNSTALL BATTERY (See Figs. 4 & 5)

............ i

CAUTION: Do not short battery termi-

meta_ bracelets, wristwatch bands,

hale.rings, Beforeetc. installing battery, remove

Positive termina_ must be connected first to prevent sparking from accideno tat grounding.

. Lift seat to raised position.

,Open battery box door.

*Lower battery into battery box with battery terminals toward front of unit.

,Be sure battery drain tube is attached to battery box.

oFirst connect RED battery cabfe to positive (+) battery terminal with hex bolt, flat washer, lock washer and hex nut as shown. Tighten securely°

*Connect BLACK grounding cable to negative (-) bat, tery terminal with remaining hex bolt, flat washer, lock washer and hex nut° Tighten securely.

oClose battery box door. Open battery box door for:

oinspection for secure connections (to tighten hard- ware).

oInspection for corrosion. , Testing battery,

, Jumping (if required). Periodic charging

BATTERY

BOX DOOR

POSiTiVENEGATIVE

(RED) CABLE

(BLACK) CABLE

FLAT

WASHER

HEX \_\

BOLT

POSITIVE (+) TERMINAL

VENT CAPS

FIGo5

/CHECKMST

BEFORE YOU OPERATE AND ENJOY YOUR NEW TRACTOR, WE WISH TO ASSURE THAT YOU RECEIVE

THE BEST PERFORMANCEAND SA TISFACT"iON FROM THIS QUALITY PRODUCT.

PLEASE REVIEW THE FOLLOWING CHECKLIST:

,/ All assembly instructions have been completed.

¢" No remaining loose parts in carton°

,/ Battery is properly prepared and charged. (Minimum 1 hour at 6 amps).

,/ Seat is adjusted comfortably and tightened securely.

,/ All tires are properly inflated, (For shipping purposes, the tires were over-inflated at the factory).

€" Be sure mower deck is properly leveled side-to-side/ front-to-rear for best cutting results. (Tires must be properly inflated for leveling).

¢' Check mower and drive belts. Be sure they are routed properly around pulleys and inside all belt keepers.

_z Check wiring, See that all connections are still secure and wires are properly clamped.

WHILE LEARNING HOW TO USE YOUR TRACTOR, PAY EXTRA ATTENTION TO 7:HE FOLLOWlNG IMPORTANT ITEMS:

,/ Engine oil is at proper level,

./ Fue! tank is filled with fresh, dean, regular unleaded gasoline.

¢" Become familiar with all controls _ their !ocation and function. Operate them before you start the engine.

,/ Be sure brake system is in safe operating condition,

RG° 4

9

Page 8 Page 10
Image 9
Page 8 Page 10
Contents Owners Manual Model no Safe Operation Practices for RideOn Mowers IV. ServiceI1. Slope Operation ChildrenMawntenance Agreement RaND Accessories AN Attachments Engine NantenancePerformance Contents of Hardwa Pack To Remove Unit from Carton Tools Required For AssemblyUnpack Carton Attach STEE!RJNG Wheel See FigNstall Seat See Fig Adjustmentlock Washer BoltCheck Tire Pressure Check Deck LevelnessCheckmst ASS LYNOW Your Tractor OperationTo Adjust Mower Cutting HIT l,,= Fig HOW to USE Your TractorTo SET Parking Brake See Fig To USE Throttle Control See FigBefore Starting the Engine OpefiatioTo Operate on Hills To TransportMowing Tips OperatioChart Maintenance ScheduleCustom Espo General RecommendationsBrake Operation TractorTires Blade CareTransaxle Cooung Transaxle Pump Fluud Level See Figs, t3Clsaning Custo E ResponsiMuffler Spark PlugsTo Removemower See Fig Ervice AN Adjustm TSTo Level Mower Housing Service AN AdjustmentsAdjustments Service ANTo Adjust Brake See Fig, ,!5 To Replace Mower Blade Drive BeltTo Adjust Motion Control Lever Service AN AdjustmentsConnector Forward AdjustmentFront Wheel TOE-IN/CAMBER To Start Engine WiTH a Weak BatteryTo Remove Wheel for Repairs See Fig To Attach Jumper CablesService ITO Replace Fuse See FigTo Replace Headlight Bulb Final Setting To Adjust Carburetor See FigPreliminary Setting Acceleration TestEngine StorageFuel System Engine OILCorrection Problem CauseTrou Leshooti G Points Problem Cause CorrectionFuse 3OAMP Wiring Insulated Clips NON-REMOVABLE ConnectionsSolenoid Pedal UP CLUTCH/BRAKEWheels and Tires DecalsKEY Part Description NO. no KEYRepair Parts Standard Hardware -- Purchase Locally KEY PartRepair Parts Chassb and Enclosures 12.5 HP 38 Riding Lawn Tractor -MODEL Number 917,255590 KEY Part Description DrhveStandard Hardware Locally3543 2324 12.5 HP 38 Riding Lawn Tractor =.. Model Number 917,255590 KEY PartDescription EQU1PM ENT KEY Part DescriptionStandard Hardware - Purchase Locally 12.5 HP 38 Riding Lawn Tractor == Model Number 917,255590 KEY Part Description KEY Part NO. noKEY Part NO. no Description Seat Assem BLYSection Repair Parts Descrbption 12.5 HP 38 R DtNG Lawn Tractor = Model Number 9!7o255590837 GasketsetSpecial Tools Required to NSTALLo 125 13114Manufacturer KEY Number005 KEY Part DsscriptionPart NO. no Suggested Guide for SiGHTiNG Slopes for Safe Operation Automatic Hydrostatic MoweLAW Tractor Part Description
Top Page Image Contents