Multiquip GAC-6HZR manual Maintenance, Daily, Weekly, Engine Oil, Engine Air Cleaner

Page 26

maintenance

Maintenance

Perform the scheduled maintenance procedures as defined by Table 5 and below:

Daily

„„Thoroughly remove dirt and oil from the engine and control area. Clean or replace the air cleaner elements as necessary. Check and retighten all fasteners as necessary.

Weekly

„„Remove the fuel filter cap and clean the inside of the fuel tank.

„„Remove or clean the filter at the bottom of the tank.

„„Remove and clean the spark plug (Figure 26), then adjust the spark gap to 0.024 ~0.028 inch (0.6~0.7 mm). This unit has electronic ignition, which requires no adjustments.

Figure 26. Spark Plug Gap

Engine Oil

1.Drain the engine oil when the oil is warm as shown in Figure 27.

2.Remove the oil drain bolt and sealing washer and allow the oil to drain into a suitable container.

3.Replace engine oil with recommended type oil as listed in Table 4. For engine oil capacity, see Table 2 (engine specifications). DO NOT overfill.

4.Install drain bolt with sealing washer and tighten securely.

Figure 27. Draining Engine Oil

Engine Air Cleaner

DANGER

DO NOT use gasoline as a cleaning solvent, the possibility exists of fire or explosion which can cause damage to the equipment and severe bodily harm or even DEATH!

1.Remove the air cleaner cover and foam filter element as shown in Figure 28.

2.Clean foam element in warm, soapy water or nonflammable solvent. Rinse and dry thoroughly. Dip the element in clean engine oil and completely squeeze out the excess oil from the element before installing.

Figure 28. Engine Air Cleaner

page 26 — GAC6HZR 60 hz gENERATOR• operation and parts manual — rev. #1 (03/31/10)

Page 25 Page 27
Image 26
Page 25 Page 27
Contents Model gaC-6HZR Table of Contents GAC6HZR Portable 60 Hz GeneratorChoose from three easy options Safety Information SaFeTY messagesGeNeRal saFeTY GeNeRaTOR saFeTYENgiNe saFeTY Fuel saFeTYGrounding safety EleCTRiCal saFeTYPower Cord/Cable safety BaTTeRY saFeTY eleCTRiC sTaRT ONlYTRaNspORTiNg saFeTY ENviRONmeNTal saFeTYPage Specifications gENERATOR Specifications GeneratorSpecifications engine Effects of Altitude and HeatDimensions 18.9 480 MMPage Installation Connecting the GroundPlacement Outdoor InstallationIndoor Installation Generator GroundingControl Box General informationGenerator Components generator HondaFuel Tank Fuel tank capacity is 5 gallons 19 liters Main/GFCI Circuit Breakers General Inspection Prior to Operation Ground Power ToolsExtension Cable Fuel Check Before StartingEngine Oil Check Starting the Engine OperationBefore Starting the Engine Place main circuit breaker in the on position Emergency Shutdown Operation/shutdownStopping the Engine Normal Shutdown Preparation for long term storage Generator StorageMaintenance First EveryDaily MaintenanceEngine Air Cleaner WeeklyGenerator wiring digram SW2Troubleshooting Engine Engine TroubleshootingWeak in power Water in fuel system? Troubleshooting Generator Page Explanation of Code in Remarks Column Suggested Spare Parts GAC6HZR- nameplate and decalS Assy 5561058 and belowPart Name GAC6HZR- Generator Assy BEARING, 6304 2RU Nycm RECTIFIER, D3SB80Surge Absorber SET BOLT, RotorGAC6HZR- Control BOX Assy Control BOX Idle Control SwitchOperation Switch Slow Down UnitGAC6HZR- Muffler Assy Bracket MufflerBOLT, HEX Head GAC6HZR- Pipe Frame Assy Rubber Suspension Pipe FrameBase StopperHonda GX340K1/U1EDN2 AIR Cleaner Assy CASE, AIR Cleaner ELEMENT, AIR CleanerSEPARATOR, AIR Cleaner STAY, AIR CleanerHonda GX340K1/U1EDN2 Engine Camshaft Assy ROD, Push SPRING, Weight ReturnIncludes ITEMS/W$ ARM, Valve RockerHonda GX340K1/U1EDN2 Engine Carburetor Assy Float SET Gasket SETValve SET, Float Chamber SET, FloatHonda GX340K1/U1EDN2 Engine Carburetor Assy STAY, Solenoid GASKET, AIR CleanerCLIP, Wire Harness LEVER, ChokeHonda GX340K1/U1EDN2 Engine Control Assy ROD, Governor SPRING, Control AdjustingARM, Governor SPRING, GovernorHonda GX340K1/U1EDN2 Engine Crankcase Cover Assy PIN, Governor Weight WEIGHT, GovernorHOLDER, Governor Weight GASKET, Case CoverHonda GX340K1/U1EDN2 Engine Crankshaft Assy WEIGHT, Balancer Honda GX340K1/U1EDN2 Engine Cylinder Barrel Assy SHAFT, Governor ARM Switch ASSY., OIL LevelWIRE, Ground BOLT, Drain PlugHonda GX340K1/U1EDN2 Engine Cylinder Head Assy GASKET, Cylinder Head GUIDE, Valve OS OptionalCLIP, Valve Guide COVER, HeadHonda GX340K1/U1EDN2 Engine FAN Assy GROMMET, Drain Hole COVER, FAN *NH1* BlackShroud Honda GX340K1/U1EDN2 Engine Flywheel Assy Flywheel COMP., Lamp FAN, CoolingPULLEY, Starter Honda GX340K1/U1EDN2 Engine Ignition Coil Assy WIRE, Stop Switch 470MM CLAMP, WireGROMMET, Wire HOLDER, Stop Switch WireHonda GX340K1/U1EDN2 Engine Piston Assy Piston STD BOLT, Connecting RODRing SET, Piston STD PIN, PistonHonda GX340K1/U1EDN2 Engine Recoil Starter Assy SPRING, Friction PULLEY, Recoil StarterRATCHET, Starter SPRING, Starter ReturnHonda GX340K1/U1EDN2 Engine Solenoid Assy Solenoid Assy SPRING, Choke ReturnLEVER, Throttle Honda GX340K1/U1EDN2 Engine Fuel Cock Assy Filter CUP PACKING, Fuel Strainer CUPRing CUP, Fuel StrainerHonda GX340K1/U1EDN2- Engine Decals Assy DECAL, Choke Gray DECAL, AIR CleanerDECAL, Choke Emblem GX240 HondaHonda GX340K1/U1EDN2 Engine Tool KIT Sapnner Wrench COMP. Spark PlugHANDLE, BOX Wrench BAG ToolTerms and Conditions of Sale Parts FReigHT pOliCYPage HERE’S HOW to GET Help

GAC-6HZR specifications

The Multiquip GAC-6HZR is a versatile and powerful gasoline generator designed for a wide range of applications, including construction sites, events, and emergency backup power. Built with reliability and performance in mind, this generator is an excellent choice for users seeking a robust power solution.

One of the main features of the GAC-6HZR is its impressive output capacity. With a maximum power output of 6,000 watts and a rated output of 5,500 watts, this generator can handle multiple tools and appliances simultaneously, making it an ideal choice for contractors and outdoor enthusiasts alike. The addition of a reliable Honda GX390 engine ensures optimal performance and fuel efficiency, allowing for extended run times between refueling.

The GAC-6HZR is equipped with an easy-to-read control panel that features multiple 120V and 240V outlets, a circuit breaker, and a gas gauge, providing users with everything they need to manage their power needs efficiently. The inclusion of a 12V DC outlet also allows for charging batteries, further enhancing its usability across different applications.

Safety considerations are paramount in the design of the GAC-6HZR. The generator includes a low-oil shutdown feature that automatically turns off the engine when oil levels drop to a dangerous level, preventing damage and extending the unit's lifespan. Additionally, its sturdy steel frame construction provides durability and protection against harsh environments.

The GAC-6HZR also integrates advanced technologies to enhance its performance and user experience. Its digital ignition system ensures easier starts in various conditions, while its noise-reducing design keeps operation quiet enough for use in residential areas or during events. Furthermore, the generator's compact and portable design, featuring ergonomically designed handles, allows for easy transportation and maneuvering on job sites or around the home.

In conclusion, the Multiquip GAC-6HZR is a powerful and reliable generator that is well-equipped to meet the demands of users in various fields. With its high output, advanced safety features, and user-friendly design, it stands out as a dependable power solution for anyone in need of portable electricity. Whether used for construction, events, or emergency power supply, the GAC-6HZR is designed to deliver exceptional performance and reliability.
Top Page Image Contents