Multiquip GAC-6HZR manual GAC6HZR- nameplate and decalS Assy, and below

Page 34

GAC6HZR— nameplate and decalS ASSY.

S/N 5561058 AND BELOW

CAUTION

Do not use in rain or snow.

1 ATTENTION

Ne pas utiliser en cas de pluie ou neige.

A3520000A

6000

7

FUEL COCK

ROBINET’ D ESSENCE

ON/OUVERT

OFF/

FERMER

A90820000

CAUTION/ATTENTION

HOT PARTS can burn skin.

DO NOT touch until the lamp has sufficiently cooled.

Danger de brûlure, pièces chaudes.

Ne touchez pas avant que l’appareil ne soit suffisamment refroidi.

A65200040A

WARNING/ATTENTION

Only operate machine in well

ventilated areas.

Do not inhale exhaust gases.

N’utilizez l’equipment que dans

des endroits bien aérés.

Ne respirez paz les gas d’échappement.

2

3

 

 

 

8

 

 

 

 

Insulation System

--- B

 

 

Maximum ambient

 

 

 

 

Temperature ---

40°C (104°F)

 

 

Systéme d’insulation

--- B

 

 

10

Température ambiante

 

maximum --- 40°C (104°F)

 

 

 

 

A33210030A

 

 

 

 

 

 

 

CAUTION

READ OWNER’S SERVICE MANUAL BEFORE OPERATING OR SERVICING THIS MACHINE.

ALWAYS KEEP UNAUTHORIZED INEXPERICENCED UNTRAINED PEOPLE AWAY FROM THIS MACHINE.

MAKE SURE ALL SAFETY DEVICES ARE OPERATIONAL BEFORE THIS MACHINE IS STARTED. MAKE SURE ENGINE IS TURNED OFF AND SPARK PLUG WIRE DISCONNECTED BEFORE SERVICING THE MACHINE OR COMING IN CONTACT WITH ANY MOVING PART. IF EQUIPMENT IS POWERED BY AN ELECTRIC MOTOR DISCONNECT ELECTRICAL PLUG.

NEVER LEAVE MACHINE UNATTENDED WHEN OPERATING ALWAYS STOP ENGINE AND ALLOW ENGINE TO COOL

BEFORE ADDING FUEL OR OIL.

A55200070A

CAUTION

IIest impératif de lire le manuel d’utilisation avant d’utiliser ou de réparer cet équipement.

II est impératif degarder tout personnel non

authorisé ou non qualifié à distance de cet equipement.

Assurez vous que tout equipement de sécurité est fonctionnel avant d’engager l’equipement. Assurez vous que le moteur est éteint et que le fil de la bougie

est d’econnecté avant de réparer la machine ou vant tout contact avec toute pièce en mouvement.

Si l’equipement est alimenté par un moteur électrique débranchez l’appareil.

Ne laissez jamis l’appareil sans supervision quand

 

il est en marche, II est impératif d’arrêter le

 

motour et de la laisser refroidir avant d’ajouter

 

de l’huile ou du carburant.

A5520080

 

 

 

 

 

Dangerous

Only qualified personnel should install, use,

 

 

 

 

or service this equipment.

 

 

 

 

Gas/Gas

Seul un personnel qualifié devrait avoir

 

 

 

 

dangereux

l’authorisation d’installer d’utilisier ou

 

 

 

A63210090A

 

de réparer cet équipement.

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Do not touch output terminals or internal

 

 

 

 

 

 

wiring while unit is operating.

 

 

 

 

 

 

Turn off power before servicing.

 

 

 

 

 

 

Ne touchez ni les terminaux externes ou le

 

 

 

 

 

 

cablage electrique interne lorsque que

 

 

 

 

 

 

l’équipement est en operation.

 

 

 

 

 

 

Eteindre avant de réparer.

 

 

 

 

 

 

 

 

 

 

 

 

Only qualified personnel should install, use,

 

 

Electrical

 

 

 

shock hazard

 

or service this equipment.

 

 

Possibilité

 

Seul un personnel qualifié devrait avoir

 

 

de choc

 

 

 

electrique

 

l’authorisation d’installer d’utilisier ou

 

 

A63210100A

de réparer cet équipement.

4

65

S/N 5561059~5582097

THE POSSIBILITY EXISTS OF ELECTROCUTION IF

GENERATOR/WELDER IS NOT PROPERLY GROUNDED.

ALWAYS CONNECT EARTH GROUND (GROUND ROD) TO

GENERATOR GROUND POINT.

IL Y AURAIT UN RISQUE D’ÉLECTROCUTION À MOINS

 

 

QUE LA GÉNÉRATRICE/SOUDEUSE NE SOIT PROPREMENT

 

 

MISE A LA TERRE. S’ASSURER DE RELIER A LA MASSE

 

 

(BARRE DE MASSE) LE POINT DE MISE A LA TERRE DE

 

 

L’APPAREIL.

 

 

 

 

GROUND ROD FOR

 

 

 

 

EARTH GROUND

 

 

 

 

BARRE DE MASSE

GROUND TERMINAL

 

 

 

 

PRISE DE TERRE

11

CONNECT TO BUILDING

 

GROUND IF REQUIRED

 

ARELIER À LA MASSE

GROUND CABLE

 

 

D’OUVRAGE EVENTUELLEMENT

#8 MINIMUM

 

 

 

 

CÂBLE DE MASSE

 

 

 

 

#8 MINIMUM

 

 

 

 

FOR FURTHER GROUNDING

 

 

8 FT.

MINIMUM

INSTRUCTIONS READ MANUAL

 

 

8 PIEDS

MINIMUM

POUR PLUS DE DÉTAILS

 

 

REFERENCE NEC 250-52 (C)

CONCERNANT LA MISE Á LA

 

 

RÉFERÉNCE NEC 250-52 (C)

TERRE, LIRE LE MANUEL

 

 

 

 

A91110020

 

 

S/N 5582098~5622598

 

DANGER

 

Using a generator indoors CAN KILL YOU IN MINUTES.

 

Utilser un générateur à l’ intérieur VOUS TUERA EN QUELQÙES MINUTES.

 

Exhaust contains carbon monoxide, a poison gas you cannot see or smell.

 

Les gaz d’ échappement contiennent du monoxyde de carbon, un gaz toxique

 

invisible et inodore.

 

12

NEVER use in enclosed or partially

ONLY use outdoors and away from

 

enclosed areas.

open windows, doors, and vents.

 

Utilisation UNIQUEMENT à l’ extér leur

 

Utilisation INTERDITE dans un

 

espace clos ou partiellement clos.

portes et trous d’ aération

 

 

 

 

A9504000104

S/N 5622599 AND ABOVE

WARNING

Operation of this equipment may create sparks that can start fires around dry vegetation.

A spark arrestor may be required. The operator should contact local fire agencies for laws or regulation relating to fire prevention requirements.

 

 

Des étincelles pouvant enflammer la

13

végétation séche environnante peuvent être

produites pendant le fonctionnement de cet

 

 

équipement.

Un pare–étincelles peut être requis. L’opérateur doit contacter les agences anti–incendie locales pour s’ informer des lois ou feglementations concernant les exigences de prévention–incendie

A90400020

page 34 — GAC6HZR 60 hz gENERATOR• operation and parts manual — rev. #1 (03/31/10)

Page 33 Page 35
Image 34
Page 33 Page 35
Contents Model gaC-6HZR Table of Contents GAC6HZR Portable 60 Hz GeneratorChoose from three easy options Safety Information SaFeTY messagesGeNeRal saFeTY GeNeRaTOR saFeTYENgiNe saFeTY Fuel saFeTYGrounding safety EleCTRiCal saFeTYPower Cord/Cable safety BaTTeRY saFeTY eleCTRiC sTaRT ONlYTRaNspORTiNg saFeTY ENviRONmeNTal saFeTYPage Specifications gENERATOR Specifications GeneratorSpecifications engine Effects of Altitude and HeatDimensions 18.9 480 MMPage Installation Connecting the GroundPlacement Outdoor InstallationIndoor Installation Generator GroundingGenerator General informationControl Box Components generator HondaFuel Tank Fuel tank capacity is 5 gallons 19 liters Extension Cable General Inspection Prior to Operation Ground Power ToolsMain/GFCI Circuit Breakers Engine Oil Check Before StartingFuel Check Before Starting the Engine OperationStarting the Engine Place main circuit breaker in the on position Stopping the Engine Normal Shutdown Operation/shutdownEmergency Shutdown Preparation for long term storage Generator StorageMaintenance First EveryDaily MaintenanceEngine Air Cleaner WeeklyGenerator wiring digram SW2Troubleshooting Engine Engine TroubleshootingWeak in power Water in fuel system? Troubleshooting Generator Page Explanation of Code in Remarks Column Suggested Spare Parts GAC6HZR- nameplate and decalS Assy 5561058 and belowPart Name GAC6HZR- Generator Assy BEARING, 6304 2RU Nycm RECTIFIER, D3SB80Surge Absorber SET BOLT, RotorGAC6HZR- Control BOX Assy Control BOX Idle Control SwitchOperation Switch Slow Down UnitGAC6HZR- Muffler Assy BOLT, HEX Head MufflerBracket GAC6HZR- Pipe Frame Assy Rubber Suspension Pipe FrameBase StopperHonda GX340K1/U1EDN2 AIR Cleaner Assy CASE, AIR Cleaner ELEMENT, AIR CleanerSEPARATOR, AIR Cleaner STAY, AIR CleanerHonda GX340K1/U1EDN2 Engine Camshaft Assy ROD, Push SPRING, Weight ReturnIncludes ITEMS/W$ ARM, Valve RockerHonda GX340K1/U1EDN2 Engine Carburetor Assy Float SET Gasket SETValve SET, Float Chamber SET, FloatHonda GX340K1/U1EDN2 Engine Carburetor Assy STAY, Solenoid GASKET, AIR CleanerCLIP, Wire Harness LEVER, ChokeHonda GX340K1/U1EDN2 Engine Control Assy ROD, Governor SPRING, Control AdjustingARM, Governor SPRING, GovernorHonda GX340K1/U1EDN2 Engine Crankcase Cover Assy PIN, Governor Weight WEIGHT, GovernorHOLDER, Governor Weight GASKET, Case CoverHonda GX340K1/U1EDN2 Engine Crankshaft Assy WEIGHT, Balancer Honda GX340K1/U1EDN2 Engine Cylinder Barrel Assy SHAFT, Governor ARM Switch ASSY., OIL LevelWIRE, Ground BOLT, Drain PlugHonda GX340K1/U1EDN2 Engine Cylinder Head Assy GASKET, Cylinder Head GUIDE, Valve OS OptionalCLIP, Valve Guide COVER, HeadHonda GX340K1/U1EDN2 Engine FAN Assy Shroud COVER, FAN *NH1* BlackGROMMET, Drain Hole Honda GX340K1/U1EDN2 Engine Flywheel Assy PULLEY, Starter FAN, CoolingFlywheel COMP., Lamp Honda GX340K1/U1EDN2 Engine Ignition Coil Assy WIRE, Stop Switch 470MM CLAMP, WireGROMMET, Wire HOLDER, Stop Switch WireHonda GX340K1/U1EDN2 Engine Piston Assy Piston STD BOLT, Connecting RODRing SET, Piston STD PIN, PistonHonda GX340K1/U1EDN2 Engine Recoil Starter Assy SPRING, Friction PULLEY, Recoil StarterRATCHET, Starter SPRING, Starter ReturnHonda GX340K1/U1EDN2 Engine Solenoid Assy LEVER, Throttle SPRING, Choke ReturnSolenoid Assy Honda GX340K1/U1EDN2 Engine Fuel Cock Assy Filter CUP PACKING, Fuel Strainer CUPRing CUP, Fuel StrainerHonda GX340K1/U1EDN2- Engine Decals Assy DECAL, Choke Gray DECAL, AIR CleanerDECAL, Choke Emblem GX240 HondaHonda GX340K1/U1EDN2 Engine Tool KIT Sapnner Wrench COMP. Spark PlugHANDLE, BOX Wrench BAG ToolTerms and Conditions of Sale Parts FReigHT pOliCYPage HERE’S HOW to GET Help

GAC-6HZR specifications

The Multiquip GAC-6HZR is a versatile and powerful gasoline generator designed for a wide range of applications, including construction sites, events, and emergency backup power. Built with reliability and performance in mind, this generator is an excellent choice for users seeking a robust power solution.

One of the main features of the GAC-6HZR is its impressive output capacity. With a maximum power output of 6,000 watts and a rated output of 5,500 watts, this generator can handle multiple tools and appliances simultaneously, making it an ideal choice for contractors and outdoor enthusiasts alike. The addition of a reliable Honda GX390 engine ensures optimal performance and fuel efficiency, allowing for extended run times between refueling.

The GAC-6HZR is equipped with an easy-to-read control panel that features multiple 120V and 240V outlets, a circuit breaker, and a gas gauge, providing users with everything they need to manage their power needs efficiently. The inclusion of a 12V DC outlet also allows for charging batteries, further enhancing its usability across different applications.

Safety considerations are paramount in the design of the GAC-6HZR. The generator includes a low-oil shutdown feature that automatically turns off the engine when oil levels drop to a dangerous level, preventing damage and extending the unit's lifespan. Additionally, its sturdy steel frame construction provides durability and protection against harsh environments.

The GAC-6HZR also integrates advanced technologies to enhance its performance and user experience. Its digital ignition system ensures easier starts in various conditions, while its noise-reducing design keeps operation quiet enough for use in residential areas or during events. Furthermore, the generator's compact and portable design, featuring ergonomically designed handles, allows for easy transportation and maneuvering on job sites or around the home.

In conclusion, the Multiquip GAC-6HZR is a powerful and reliable generator that is well-equipped to meet the demands of users in various fields. With its high output, advanced safety features, and user-friendly design, it stands out as a dependable power solution for anyone in need of portable electricity. Whether used for construction, events, or emergency power supply, the GAC-6HZR is designed to deliver exceptional performance and reliability.
Top Page Image Contents