Multiquip GA4.5RA GA-4.5R/GA-4.5RA Controls and Indicators, Generator Controls and Components

Page 15

GA-4.5R/GA-4.5RA — CONTROLS AND INDICATORS

Figure 2A. Generator Controls and Components

1.

Lifting Bail Eye – Attach a rope or chain to this lifting eye

 

when lifting of the generator is required. Never stand

 

underneath the generator while it is being lifted. Place lifting

 

eye in down position when not in use.

2.

AC-Voltmeter – This voltmeter indicates (with a mark) the

 

rated 60 Hz, single phase output voltage. In addition the

 

voltmeter can also be used as a diagnostic tool. If the

 

voltmeter indicator (needle) is below the rated voltage,

 

engine problems may exist (low/high RPM's). To prevent

 

damage to the generator or power tools turn the generator

 

OFF and consult your authorized MQ service dealer.

3. Idle Control Switch – This unit is provided with an automatic idle control for noise suppression and reduced fuel consumption.The automatic idle control automatically engages under a no-load condition. With the automatic idle control switched “ON”, the engine revolutions will automatically drop to about 2600 rpm (low-speed operation) within 3 seconds after the load stops. When the operation is resumed, the engine speed is automatically increased to about 3600 rpm (high-speed operation) as soon as the load is connected.

4. Operation Switch – Place this rocker switch in the "RUN" position (up) for normal operation.To turn-off the generator place this switch in the "STOP" position (down).

5. GFCI Duplex Receptacle – NEMA 5-20R receptacle will provide 120V, 20 amps.The position of the full power switch does not effect the voltage output at the receptacle. The GA-4.5RA has two GFCI receptacles.

6. 120 VAC Receptacle – NEMA L5-20R twist-lock receptacle will provide 120V, 20 amps when the full power switch is placed in either the 120 or 240 volt position.

7. 120 VAC Receptacle – NEMA L5-30R twist-lock receptacle will provide 120V when the full power switch is placed in either the 120 or 240 volt position.

8. 240 VAC Receptacle – NEMA L14-20R twist-lock receptacle will provide 240V when the full power switch is placed in the 240/120 volt position (down). When the full power switch is placed in the 120 volt position (up), 120V will be available.

9. Main Circuit Breaker – 2-pole circuit breaker (240V/18.75 amps or 120V/30.8 amps) protects the generator from short circuiting or overloading. When starting the generator always have the circuit breaker placed in the "OFF" position.

10. Frame Ground – This ground connection point should be connect to a good earth ground (ground rod).

GA-4.5R/GA-4.5RA A.C. GENERATOR — OPERATION & PARTS MANUAL — REV. #1 (11/27/06) — PAGE 15

Page 14 Page 16
Image 15
Page 14 Page 16
Contents Model GA4.5R/GA4.5RA Page Page Table of Contents Parts Ordering Procedures Best Deal! Order via Internet Dealers OnlyOrder via Fax Dealers Only Hazard Symbols GA-4.5R/GA-4.5RA Safety Message Alert SymbolsThis generator, other property GA-4.5R/GA-4.5RA Rules for Safe Operation GA-4.5R/GA-4.5RA Rules for Safe Operation Power Cord SafetyEmergencies DeathGA-4.5R/GA-4.5RA Specifications Dimensions GA-4.5R/GA-4.5RA DimensionsGeneral Inspection Prior to Operation GA-4.5R/GA-4.5RA General InformationExtension Cables GA-4.5R/GA-4.5RA Load ApplicationGenerator Controls and Components GA-4.5R/GA-4.5RA Controls and IndicatorsWhen the full power switch is Fuel Gauge Read this gauge to determine when fuel is low Generator Refueling GA-4.5R/GA-4.5RA Generator RefuelingGA-4.5R/GA-4.5RA Installation Indoor InstallationGenerator Grounding Connecting the Ground GA-4.5R/GA-4.5RA InstallationLoad In Watts General Inspection Prior to Operation Ground Power ToolsExtension Cable Main Circuit BreakerFuel Check GA-4.5R/GA-4.5RA PRE-INSPECTION EngineBefore Starting Engine Oil CheckBefore Starting the Engine GA-4.5R/GA-4.5RA Initial START-UP EngineNoises that would associate with lose components GA-4.5R/GA-4.5RA Initial START-UP ENGINE/OPERATION120 VAC Receptacle Main Circuit Breaker on Stopping The EngineGenerator Storage GA-4.5R/GA-4.5RA Preparation for Long -TERM StorageEngine Maintenance Schedule GA-4.5R/GA-4.5RA Maintenance EngineSpark Plug Gap Engine Air CleanerPage Generator/Engine Wiring Diagram GA-4.5R Only MQ GA-4.5R -WIRING DiagramMQ GA-4.5RA -WIRING Diagram GA-4.5R/GA-4.5RA -TROUBLESHOOTING Engine White GA-4.5R/GA-4.5RA -TROUBLESHOOTING EngineGenerator Troubleshooting GA-4.5R/GA-4.5RA -TROUBLESHOOTING GeneratorPage QTY. Column GA-4.5R/GA-4.5RA Explanation of Code in Remarks ColumnNO. Column Part NO. ColumnTo 3 Units GA-4.5R/GA-4.5RA Suggested Spare PartsGA-4.5R/GA-4.5RA Name Plate and Decals Part Name QTY Remarks GA-4.5R/GA-4.5RA Generator Assy Part Name QTY. Remarks MQ GA-4.5R Control BOX Assy Part Name MQ GA-4.5RA Control BOX Assy A3214000103 GA-4.5R/GA-4.5RA Pipe Frame Assy MQ GA-4.5R/GA-4.5RA Robin EX270D20220 Crankcase Assy Valve Guide Robin EX270D20110/EX270D20220 Crankshaft and Piston Assy Crankshaft CP Robin EX270D20110/EX270D20220 Governor Assy Governor Lever Robin EX270D20110/EX270D20220 Intake and Exhaust Assy Robin EX270D20110/EX270D20220 Intake and Exhaust Assy Robin EX270D20110/EX270D20220 Muffler Assy MUFFLER, CP Robin EX270D20110/EX270D20220 AIR Cleaner Assy Body CP Robin EX270D20110/EX270D20220 Recoil Starter Assy Blower Housing CP Robin EX270D20110/EX270D20220 Carburetor Assy Valve Throttle Robin EX270D20110/EX270D20220 Flywheel Assy Flywheel CP Payment Terms Page Heres HOW to GET Help

GA4.5RA, GA4.5R specifications

The Multiquip GA4.5R and GA4.5RA are advanced generators designed for professionals who require reliable power sources across various applications. Engineered with cutting-edge technologies, these models stand out in the competitive generator market.

One of the key features of the GA4.5R and GA4.5RA is their robust power output. Both models are capable of delivering 4.5 kW of continuous power, making them suitable for a range of applications from construction sites to outdoor events and emergency backup. This reliable output is coupled with a reputable eco-friendly engine that minimizes fuel consumption while providing consistent power.

The design of the GA4.5R and GA4.5RA generators emphasizes ease of use and portability. With a compact and lightweight structure, these generators can be easily transported, making them ideal for users on the go. A user-friendly control panel enhances operational convenience, allowing users to monitor performance metrics such as voltage and frequency effortlessly.

In terms of durability, Multiquip has ensured that both models are built with high-quality materials that can withstand demanding conditions. The sturdy frame offers protection against falls and impacts, while the weather-resistant housing protects internal components from external elements. This rugged design guarantees longevity, making these generators a solid investment for users.

The GA4.5RA model introduces advanced technology with its electric start feature, adding even more convenience for users. This eliminates the need for manual recoil starting, making the generator easy to operate, especially in low-light conditions or for those who may have difficulty with traditional starting methods.

Additional safety features are integrated into both models, including low oil shutdown and circuit breaker protection, ensuring that the generator operates securely and efficiently. This attention to safety appeals to professionals who rely on their equipment to perform at optimal functionality without compromising user safety.

To summarize, the Multiquip GA4.5R and GA4.5RA generators are designed with power, portability, and durability in mind. Their advanced features and technologies cater to a variety of applications, making them an invaluable tool for anyone in need of reliable power solutions. With Multiquip's reputation for quality and performance, these models are poised to meet the demanding expectations of users across different industries.
Top Page Image Contents