Multiquip ga-6h manual GA-6H/GA-6HA Controls and Indicators

Page 19

GA-6H/GA-6HA — CONTROLS AND INDICATORS

Figure 3E. Generators Components

12. Fuel Cock Lever – Turn this lever downward to start (down)the flow of fuel into the carburetor.Turn upward to stop (up) the flow of fuel.

13. Spark Plug – Provides spark to the ignition system. Set spark plug gap to 0.6 - 0.7 mm (0.028 - 0.031 inch) Clean spark plug once a week.

14. Muffler/Heat Shield – Used to reduce noise and emissions. NEVER touch this heat shield when the generator/welder is in use. Always allow time for the generators to cool down before performing maintenance.

15. Choke Lever – Used for starting the engine. Close the choke lever when starting a cold engine or in cold weather conditions.The choke enriches the fuel mixture. Open the choke lever if starting a warm engine or in warm weather conditions.

16. Recoil Starter (pull rope) – Manual-starting method. Pull the starter grip until resistance is felt, then pull briskly and smoothly.

17.Engine Oil Filler Cap – Remove this cap/dipstick when the adding of engine oil is required. See Table 5 for recommended type engine oil.

18.Engine Oil Drain Plug – Remove this drain plug when draining of the oil from the engine crankcase is required. Fill with recommeded type oil as listed in Table 6.

19. Air Cleaner – Prevents dirt and other debris from entering the fuel system. Remove wing-nut on top of air filter cannister to gain access to filter element. NEVER run the engine without an air cleaner.

20. Fuel Tank Cap – Remove this cap to add unleaded gasoline to the fuel tank. Replenish with clean unleaded gasoline. Make sure cap is tightened securely. DO NOT over fill.

21. Fuel Gauge – This gauge is located on top of the fuel tank. Read this gauge to determine when fuel is low.

22. FuelTank – Fuel tank capacity is 5 gallons (19 liters).

This HONDA engine is equipped with a low oil shutdown capability. A

NOTE built in sensor will automatically turn off the engine should the oil level fall below a safe operating condition. Make sure the generators is placed

on level ground. Placing the generators on level ground will ensure that the low oil sensor will function properly.

GA-6H/GA-6HA A.C. GENERATORS — OPERATION & PARTS MANUAL — REV. #0 (06/02/05) — PAGE 19

Page 18 Page 20
Image 19
Page 18 Page 20
Contents Model GA-6H/GA-6HA Page Heres HOW to GET Help Table of Contents When ordering parts Please supply the following information Parts Ordering ProceduresBurn Hazards GA-6H/GA-6HA Safety Message Alert SymbolsRespiratory Hazards Rotating Parts Hazards Equipment DamageRead this manual GA-6H/GA-6HA Rules for Safe OperationPower Cord Safety Emergencies DeathOperation and Safety Decals Machine Safety DecalsEffects of Altitude and Heat GA-6H/GA-6HA Specifications GeneratorsGA-6H/GA-6HA Specifications Engine Specifications EngineDimensions GA-6H/GA-6HA DimensionsGA-6H/GA-6HA General Information Large Motors Single Phase Load 60 HzIncandescent Loads Small MotorsGenerators Components GA-6H/GA-6HA Controls and IndicatorsWhen the full power switch is FuelTank Fuel tank capacity is 5 gallons 19 liters GA-6H/GA-6HA Controls and IndicatorsGenerators Refueling GA-6H/GA-6HA Generator RefuelingMounting GA-6H/GA-6HA InstallationOutdoor Installation Indoor InstallationConnecting the Ground GA-6H/GA-6HA InstallationMain Circuit Breaker General Inspection Prior to Operation Ground Power ToolsGA-6H/GA-6HA PRE-INSPECTION Extension CableFuel Check GA-6H/GA-6HA PRE-INSPECTION EngineBefore Starting Engine Oil CheckBefore Starting the Engine GA-6H/GA-6HA Initial START-UP EngineGA-6H/GA-6HA Initial START-UP/GENERATOR Operation Stopping the Engine Connecting the LoadGenerators Storage GA-6H/GA-6HA Preparation for Longterm StoragePage Engine Maintenance Schedule GA-6H/GA-6HA Maintenance EngineMaintenance GA-6H/GA-6HA Maintenance EngineGA-6H Wiring Diagram GA-6H -WIRING Diagram GeneratorGA-6HA Wiring Diagram GA-6HA -WIRING Diagram GeneratorEngine Troubleshooting GA-6H/GA-6HA -TROUBLESHOOTING EngineWhite Generator Troubleshooting GA-6H/GA-6HA -TROUBLESHOOTING GeneratorPage Items Found In the Items Number Column How to read the marks and remarks used in this partsGA-6H/GA-6HA Explanation of Code in Remarks Column Items Found In the Remarks ColumnDescription GA-6H/GA-6HA Suggested Spare PartsName Plate Assy GA-6H/GA-6HA Nameplate and DecalsDecal Operating Instructions Decal MQ MultiquipDecalwarning Generator Assy GA-6H/GA-6HA Generator AssySET WASHER, Bearing RECTIFIER, D3SB80BEARING, 6304 2RU Nycm SET BOLT, RotorControl BOX ASSY. GA-6H GA-6H Control BOX AssyControl BOX Full Power SWITCH, ET-330D12Idle Control SWITCH, C1550WA Operation SWITCH, C1550WAControl BOX Assy GA-6HA Control BOX AssyGA-6HA Control BOX Assy Muffler Assy GA-6H/GA-6HA Muffler AssyHEX NUT MufflerBolt HEX Head BracketPipe Frame Assy GA-6H/GA-6HA Pipe Frame AssyFuel Tank GA-6HABase Rubber SuspensionAIR Cleaner Assy Honda GX340K1EDE2 Engine AIR Cleaner AssySTAY, AIR Cleaner ELEMENT, AIR CleanerSEPARATOR, AIR Cleaner HOUSING, AIR CleanerCamshaft Assy Honda GX340K1EDE2 Engine Camshaft AssyLIFTER, Valve SPRING, Weight ReturnROD, Push ARM, Valve RockerCarburetor Assy Honda GX340K1EDE2 Engine Carburetor AssyValve SET, Float GASKET, AIR CleanerCLIP, Wire Harness Gasket SETControl Assy Honda GX340K1EDE2 Engine Control AssySPRING, Governor SPRING, Control AdjustingARM, Governor ROD, GovernorCrankcase Cover Assy Honda GX340K1EDE2 Engine Crankcase Cover AssyGASKET, Case Cover WEIGHT, GovernorHOLDER, Governor Weight PIN, Governor WeightCrankshaft Assy Honda GX340K1EDE2 Engine Crankshaft AssyCrankshaft E-TYPE WEIGHT, BalancerCylinder Barrel Assy Honda GX340K1EDE2 Engine Cylinder Barrel AssyBOLT, Drain Plug Switch ASSY., OIL LevelWIRE, Ground SHAFT, Governor ARMCylinder Head Assy Honda GX340K1EDE2 Engine Cylinder Head AssyGASKET, Cylinder Head GUIDE, Valve OS OptionalGUIDE, EX. Valve OS Optional CLIP, Valve GuideFAN Cover Assy Honda GX340K1EDE2 Engine FAN Cover AssyShroud COVER, FAN *NH1* BlackGROMMET, Drain Hole Flywheel Assy Honda GX340K1EDE2 Engine Flywheel AssyFLYWHEEL, Lamp FAN, CoolingNUT, Special 16MM Ignition Coil Assy Honda GX340K1EDE2 Engine Ignition Coil AssyHOLDER, Stop Switch Wire CLAMP, WireGROMMET, Wire WIRE, Stop Switch 470MMPiston Assy Honda GX340K1EDE2 Engine Piston AssyPIN, Piston BOLT, Connecting RODRing SET, Piston STD Piston STDHonda GX340K1EDE2 Engine Recoil Starter Assy SPRING, Starter Return PULLEY, Recoil StarterRATCHET, Starter SPRING, FrictionSolenoid Assy Honda GX340K1EDE2 Engine Solenoid AssyLEVER, Throttle SPRING, Choke ReturnLabels Assy Honda GX340K1EDE2 Engine Labels AssyMARK, OIL Caution MARK, AIR CleanerEmblem MARK, ChokeEffective October 1, 2002 Terms and Conditions of Sale Parts Page Your Local Dealer is
Related manuals
Manual 2 pages 55.13 Kb

ga-6h, GA-6HA specifications

The Multiquip GA-6HA is a versatile and robust generator designed to meet the power needs of a variety of applications, particularly in construction, events, and emergency backup situations. With its compact design and impressive performance capabilities, the GA-6HA is an ideal choice for professionals and contractors who require reliable electrical supply in remote locations or during power outages.

One of the standout features of the GA-6HA is its powerful 6,000-watt output, which provides sufficient power to run multiple tools and equipment simultaneously. This generator is equipped with a Honda GX390 engine, known for its durability and fuel efficiency. The engine operates quietly, making it suitable for use in noise-sensitive environments. Furthermore, the advanced design of the engine ensures minimal emissions, aligning with environmental regulations and promoting cleaner operation.

In terms of technology, the GA-6HA is fitted with a heavy-duty alternator that delivers stable power with a rated output of 120/240 volts. This feature allows users to connect various electrical devices without worry of voltage fluctuations that could damage sensitive equipment. The generator also incorporates a manual reset circuit breaker for added safety, preventing overload conditions.

Durability is a significant characteristic of the GA-6HA, as it is built with a rugged steel frame that can withstand the rigors of outdoor use. The generator's design includes an integrated lift hook for easy transport and positioning on job sites. Additionally, the anti-vibration mounts help to minimize noise and maintain stability during operation.

The GA-6HA features multiple outlets, including 120V 20A duplex receptacles and a 120/240V 30A locking receptacle, providing flexibility for connecting various tools and appliances. An easy-to-read fuel gauge and easy-access control panel contribute to user-friendliness and operational efficiency.

Overall, the Multiquip GA-6HA is designed to be a reliable power solution, effectively combining performance, durability, and portability. Whether for construction sites, outdoor recreational activities, or emergency power needs, this generator stands out for its impressive features and user-centric design.
Top Page Image Contents