Dixon 501 manual Repeat procedure on right side

Page 11

Page 8

UPPER CONTROL LEVER INSTALLATION

1.Raise rear body cover to fully open position.

2.Insert left upper control lever on swivel plate.

3. Install fiber washer and jam nut.

;

4.Proper tightness or tension on jam nut is achieved when swing out movement of upper control levers requires some pressure. Levers should not fall to the side or be sloppy in movement.

5.Repeat procedure on right side.

Image 11

Contents Page Troubleshooting SafetyWarranty Policy Specifications SET UP and Service Care and MaintenanceImportant Read Carefully See your dealer for warranty service, parts and repairsSatisfactory use of this product Always look behind you before backing upNever carry passengers Safety Safety Reminders Read Carefully Before OperationPage Warranty Policy What is not covered by Dixon Industries, IncProduct updates or improvements Blade Drive Warner electric clutch Dimensions Width Height LengthSpecifications Subject to Change Without Notice AftSET UP and Service Insert the 2 cover. Firmly body is raised Seat Assembly InstructionsRepeat procedure on right side Position mower deck under chassis Mower Deck InstallationLeveling the Deck Mower Deck Leveling ProcedureLeveling Principals Final Preparation Cells that are lowNo shifting or clutching required Fuse Block Throttle Control LeverMqker Deck CUT Height Lift Lever Blade DriveCare and Maintenance Model Belt Tension Reverse procedure to re-install deck assemblyCutter Blade Removal Care and Maintenance Model Repeat above procedures on opposite hydrostatPage Adjustment Points for T-BOX Belt Tension Forward lever stop adjustment OIL Recommendations Each front wheel casterPrimary and final drive Engine manufacturerCare and Maintenance Model Cleaning the Mower Ground speed Reduce mowing speed Loose belts Adjust per operators ManualUnlevel mower deck Adjust per operators Manual Check and adjust asOn one side or Manual Other Mower pulls to one Drive adjustmentRepair Loss of drive power Side or the other ManualBroken wiring Repair Battery Required Battery water lowMower Battery discharge Low battery conditionIllustration Mower Deck Assembly 50 Model Illustration Body Assembly Model Illustration Transmission Assembly Model Illustration -Chassis Assembly Model ZTR 501 Parts List PART# Description Swivel Bracket Control Lever Right ZTR 501 Pasts List PART# Description