Dixon 13086-0601 manual Cutter Blade Maintenance, No trash guard on 30 machines

Page 32

CARE AND MAINTENANCE

CUTTER BLADE MAINTENANCE:

CAUTION Stop engine and remove ignition key for safety. Wear heavy, thick gloves when holding onto cutter blade, avoid the sharp edge of the blade.

Check sharpness of mower blades after every 10 hours of operation. Observe proper blade position prior to removal.

1.Safely raise front of mower.

2. Hold or block blade from turning.

3. Loosen blade nut and remove blade.

4.When replacing blade, tighten blade nut securely. Refer to diagram. Be

sure blade is centered on pilot before tightening nut to 60 ft. lbs.

(No trash guard on 30” machines)

Blades should be discarded when worn excessively.

DANGEROUS!

DO NOT USE

BLADE IN THIS

CONDITION!

New Blade

When notch starts, discard blade

32

Image 32

Contents OPERATOR’S Manual Important Read Carefully Index Safety Safety Alert Symbol General Operation General Operation Slope Operation Do notChildren Never allow children to operate the mowerService Service Dixon Limited Warranty Policy Specifications Model ZTRBladedrive Mowerdecks Seat Adjustment Instructions Models ZTR 3303 3304Controls Control LeversTransmission Drive System Parking BrakeTo SET Parking Brake Blade Drive Operation Instructions TowingBefore Operating Mower Starting Instructions Testing of Safety Interlock Systems Side Discharge of the Clippings Grass Height and Cutting Suggestions Mowing with a Mulching Attachment Mowing with a Mulching Attachment Mowing with a Grass Catcher Attachment Mowing with a Grass Catcher Attachment Care and Maintenance Maintenance ScheduleTires BatteryEngine Cutter Blade Maintenance No trash guard on 30 machinesBelts Belt TensionDeck Removal Manual Clutch Models 3303 Deck Removal Electric Clutch Model Place cut height lever in lowest cut positionFuel Shut OFF Valve LubricationChanging the Engine OIL OIL FillMaintenance Drive System AdjustmentsRear Chain Adjustment Cleaning the Mower WarrantyPARTS/SERVICE Electrical SystemsTroubleshooting Engine Runs but Mower WON’T Move Forward Model ZTR 3014 42 Deck Model ZTR 3303Model ZTR 3014 36 Deck Owner Information ZTRMowers