Bolens 18M warranty Setup Adjustments, Center top of bag attaches from the inside of bag

Page 6

3

Setup and

Adjustments

WARNING

Disconnect and ground the spark plug wire as instruct- ed in the separate engine manual.

IMPORTANT This unit is shipped

WITHOUT GASOLINE or OIL. After as- sembly, service the engine with gasoline as instructed in the engine section of this manual.

IMPORTANT Make sure to route

AB

B

Figure 3-1

Figure 3-2

A

B

NOTE: The units illustrated may vary slightly from your unit.

1.Remove any packing material which may be between upper and lower handles.

a.Pull up and back on the upper handle to raise the handle from position A into the operating position. See Figure 3-1.

b.Tighten hand knobs securing upper handle to lower handle. Make sure that each carriage bolt is seated properly in the handle.

2.Tighten star knobs securing lower handle to handle brackets. See Figure 3-2. Make sure that each carriage bolt is seated properly in the handle.

3.Rope guide Setup as follows, see Figure 3-3:

a.Hold the blade control against the upper handle. Position A.

b.Slowly pull starter rope out of engine. Position B.

c.Slip starter rope into the rope guide. Position C.

d.Tighten rope guide wing nut. Position D.

4.Secure cables to the lower handle using the cable tie. Pull cable tie tight and cut off excess.

5.To assemble the grasscatcher:

a.Place bag over frame (black plastic side is the bottom of bag.) Insert the hooks on the frame through the holes in the side plastic channels of the bag. See Figure 3-4.

b.Secure bag to frame by working the plastic channels on bag over frame. All of the plastic channels except center top of bag attach from the outside of bag.

Center top of bag attaches from the inside of bag.

6.Before attaching the grass catcher, the rear mulching plug must be removed. Refer to Figure 3-5.

a.Lift rear discharge door.

b.Remove rear mulching plug.

7.Attaching Grass Catcher to Mower

a.Lift the rear discharge door.

b.Place the grass catcher on the pivot rod. Let go of discharge door so that it rests on the grass catcher. See Figure 3-6.

A

cable outside the lower handle. Do not crimp cable while lifting the handle up.

C

D

C

B

Figure 3-3

Figure 3-4

Page 5 Page 7
Image 6
Page 5 Page 7
Contents Inch Rotary Lawn Mower Model 18M 769-03084A11/02/07 Table of Contents Finding and Recording Model NumberCustomer Support Slope Gauge General Operation Your Responsibility Restrict the useSlope Operation Service General ServiceChildren Setup Adjustments Center top of bag attaches from the inside of bagAdjustments Cutting HeightKnow Your Lawn Mower Starting Engine Using Your Lawn MowerOperating Your Lawn Mower Stopping EngineMaintenance Blade Adapter Rear Flap ReplacementOff-Season Storage Blade Mounting TorqueTrouble Shooting Problem Cause RemedySafety Labels Important This engine is shipped without gasoline or oil Know Your EngineCheck Oil Level Pre-Operation Check Oil RecommendationsCheck Fuel Level Operating Your EngineFuel Recommendations Starting The EngineOil Service Maintaining YourOil Change Air Cleaner Service Spark Plug ServiceMaintaining Your Engine Storage Fuel Filter ServiceClean Engine Removing From StorageWarranty 10.30.06Engine/Moteur 1P70 Adressez-vous au «Service après-vente» Parts List Pièces DétachéesFor parts and/or accessories refer to customer support on Description Désignation RéfModel 18M Part RÉF Pièce Description MANUFACTURER’S Warranty Coverage EPA-1 Owner Responsibilities General ConditionsGénéral d’ordre Conditions Propriétaire du ResponsabilitésGarantie la par couvertes non conditions et Pièces CA-1-EPA Propriétaire DU Responsabilités Garantie 06.30.10Remisage Service en RemiseCarburant* à filtre du Entretien Moteur du NettoyageMousse en Cartouche Air à filtre du EntretienBougie CartoucheOu moteur le d’incliner ’huile de Vidange’essence panne en tombe Avant AvertissementCarburant le concernant Recommandations Moteur du Arrêt’huile concernant Recommandations Moteur le avec vous-Familiarisez’huile niveau du Vérification Sécurité de Étiquettes Sabilité -RESPON VotreSolution Cause Problème DépannageEntretien Général d’ordre Recommandations Utilisation ’utilisation ConseilCommandes Réglage Herbe Sac du haut le contre pas repose neFigure la Voir .herbe GuidonSécurité de Consignes Responsabilité Votre Faire ÀInclinomètre ArbreModèle de numéro le trouver Pour Vente-après ServiceVente-après service au d’abord adresser vous sans Matières des TableImportant 18M Modèle po 19 de Rotative Tondeuse 11/2/0703084A-769

18M specifications

The Bolens 18M is a versatile and robust lawn and garden tractor that has been designed to meet the needs of both residential and commercial users. Known for its durability and performance, the Bolens 18M exemplifies the qualities that homeowners and landscapers look for in a reliable outdoor equipment.

One of the main features of the Bolens 18M is its powerful 18-horsepower engine, which provides ample power for a variety of tasks, from mowing to hauling heavy loads. The engine is paired with a hydrostatic transmission, allowing for smooth and seamless operation. This feature enables users to change speed without the need for manual gear shifting, providing ease of use for all skill levels.

The design of the Bolens 18M is characterized by a strong steel frame and heavy-duty construction, ensuring it can withstand the rigors of regular use. The tractor is equipped with a wide cutting deck, typically around 42 inches, which allows for efficient mowing of larger areas in less time. Additionally, the cutting height can be easily adjusted to suit different types of grass and landscaping needs.

Another noteworthy technology in the Bolens 18M is its ergonomic steering and control layout. The tractor features a comfortable seat with armrests, enhancing the user's comfort during prolonged use. This design ensures that operators can maneuver the tractor with minimal fatigue, promoting efficiency and productivity.

The Bolens 18M also offers various attachment options, expanding its functionality beyond just mowing. Attachments such as snow blowers, tillers, and dump carts can be easily integrated, transforming the tractor into a multi-use gardening tool. This versatility is particularly appealing for homeowners looking to maintain their properties year-round.

Safety features are also a priority in the Bolens 18M design, with built-in mechanisms such as an automatic blade brake that stops the blades immediately when the operator leaves the seat, preventing any accidents.

In summary, the Bolens 18M stands out with its powerful engine, user-friendly hydrostatic transmission, adjustable cutting deck, ergonomic design, and versatility through attachments. With its solid build and thoughtful features, it continues to be a popular choice for those seeking reliable equipment for their lawn care and gardening tasks. Whether for residential use or commercial landscaping, the Bolens 18M delivers performance and innovation that users can depend on.
Top Page Image Contents