GOLD
Outdoor Natural Gas Barbecue Grill Model No. GBC873WNG4.If odor continues, keep away from the appliance and immediately call your gas supplier or your fire department.
Do not store or use gasoline or other flammable liquids or vapors in the vincinity of this or any other appliance.
DANGER: Failure to follow the dangers, warnings and cautions in this manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property.
WARNING:
This grill is for outdoor use only, and shall not be used in a building, garage, or any other enclosed area.
Do NOT operate, light or use this appliance within 8 feet of walls, structures or buildings.
This grill is NOT for commercial use.
This grill is for use with Natural Gas (NG) gas only. The conversion to or attempted use of liquid propane gas (LP) in this NG gas grill is dangerous and will void your warranty.
Installation and repairs should be done by a qualified service person.
NG Characteristics:a. NG is flammable and hazardous if handled improperly. Become aware of the characteristics before using any NG product.
b. NG is explosive under pressure, heavier than air, and settles and pools in low areas.
c. NG in its natural state has no odor. For your safety, an odorant is added that smells like rotten cabbage.
d. Contact with NG can cause freeze burns to skin.e. A fire causing, serious injury or damage to property may occur if the above is not followed exactly.
Never attempt to attach this grill to the NG system of a camper trailer, or motor home.
The use of alcohol, or prescription or
Never use LP gas, charcoal, lighter fluid, lava rocks, gasoline, kerosene, or alcohol with this product.
Your grill has been checked at all factory connections for leaks. Recheck all connections, as movement in shipping can loosen connections.
Check for leaks even if your unit was assembled for you by someone else.
Do not operate if gas leak is present. Gas leaks may cause a fire or explosion.
You must follow all
a. Always perform leak test before lighting the grill and each time the grill is connected for use.
b. No smoking. Do not use or permit sources of ignition in the area while conducting a leak test.
c. Conduct the leak test outdoors in a
If you are unable to stop a leak, turn off the main valve on the NG supply line. Call a gas appliance serviceman or your local NG supplier.
The appliance and its individual shutoff valve must be disconnected from the gas supply piping system during any pressure testing of that system at a pressures in excess of 1/2 psig (3.5 kpa).
The appliance must be isolated from the gas supply piping system by closing its individual manual shutoff valve during any pressure testing of the gas supply piping system at test pressures equal to or less than 1/2 psig (3.5 kpa).
Always perform a leak test on gas connections whenever this grill is serviced. Never use a flame to test for leaks. Do not smoke while performing leak check.
Do not store or use gasoline or other flammable liquids or vapors within 25 feet (7.62 m) of this appliance.
Do not use in an explosive atmosphere. Keep grill area clear and free from combustible materials, gasoline and other flammable vapors and liquids.
Minimum clearance from sides and back of unit to combustible construction, 21 inches from side and 21 inches from back. Do not use this appliance under overhead combustible surfaces.
It is essential to keep the grill’s valve compartment, burners, and circulating air passages clean. Inspect grill before each use.
Do NOT alter grill in any manner.
Do not use the grill unless it is COMPLETELY assembled and all parts are securely fastened and tightened.
This grill should be thoroughly cleaned and inspected on a regular basis. Clean and inspect the hose before each use of the appliance. If there is evidence of abrasion, wear, cuts, or leaks, the hose must be replaced prior to the appliance being put into operation.
Use only the regulator and hose assembly provided. The replacement regulator and hose assembly shall be that specified by the manufacturer.
Use only Blue Rhino Global Sourcing, Inc factory authorized parts. The use of any part that is not factory authorized can be dangerous. This will also void your warranty.
Do not use this appliance without reading “Operating Instructions” in this manual.
Do not touch metal parts of grill until it has completely cooled (about 45 min.) to avoid burns, unless you are wearing protective gear (pot holders, gloves, BBQ mittens, etc.).
When cooking, fire extinguishing materials shall be readily accessible. In the event of an oil grease fire, do not attempt to extinguish with water. Use type BC dry chemical fire extinguisher or smother with dirt, sand or baking soda.
Do not install or use in or on boats or recreational vehicles.
Do not use grill in high winds.
Never lean over the grill when lighting.
Do not leave a lit grill unattended, especially keep children and pets away from grill at all times.
Do not attempt to move grill when in use. Allow the grill to cool before moving or storing.
Always open grill lid carefully and slowly as heat and steam trapped within grill can severely burn you.
Always place your grill on a hard
Move gas hoses as far away as possible from hot surfaces and dripping hot grease.
Keep all electrical cords away from a hot grill.
Do not use grill for indoor cooking or heating. TOXIC fumes can accumulate and cause asphyxiation.
After a period of storage and/or nonuse, check for leaks, burner obstructions and inspect for any abrasion, wear, cuts to the hose.
Failure to open lid while igniting the grill’s burners, or not waiting 5 minutes to allow the gas to clear if the grill does not light, may result in an explosive
If grill is not in use, the gas must be turned off at the main supply line.
Never operate grill without heat plates installed.
Always use a meat thermometer to ensure food is cooked to a safe temperature.
This grill is designed with to operate at an inlet pressure of 7 inches water column.
Please use protective gloves when assembling this product.
Do not force parts together as this can result in personal injury or damage to the product.
Never cover entire cooking area with aluminum foil.
Deaths, serious injury or damage to property may occur if the above is not followed exactly.