Outdoor LP Gas Barbecue Grill Model No. GBT10039L / 0184543
Troubleshooting
| Problem | Possible Cause | Prevention/Cure | |
|
|
| |
| ,0 GAS TANK IS LOW OR EMPTY | 2EPLACE ,0 GAS TANK | |
|
|
| |
| ,0 GAS LEAK | &OLLOW h#HECKING FOR ,EAKSv INSTRUCTIONS IN THE OWNERS MANUAL | |
|
|
| |
| 7IRES OR ELECTRODE COVERED WITH COOKING RESIDUE | #LEAN WIRE ANDOR ELECTRODE WITH RUBBING ALCOHOL | |
|
|
| |
| %LECTRODE AND BURNERS ARE WET | 7IPE DRY WITH CLOTH | |
| Burner will not light using ignitor | %LECTRODE CRACKED OR BROKEN SPARKS AT CRACK | 2EPLACE ELECTRODE PLEASE CALL OUR #USTOMER #ARE AT | |
| (if included) |
|
| |
Wire loose or disconnected | 2ECONNECT WIRE OR REPLACE ELECTRODEWIRE ASSEMBLY PLEASE CALL OUR #USTOMER | ||
| |||
| #ARE AT | ||
|
| ||
|
|
| |
| 7IRE IS SHORTING SPARKING BETWEEN IGNITOR AND ELECTRODE | 2EPLACE IGNITOR WIREELECTRODE ASSEMBLY PLEASE CALL OUR #USTOMER #ARE AT | |
| |||
|
| ||
|
|
| |
| Bad ignitor | 2EPLACE IGNITOR PLEASE CALL OUR #USTOMER #ARE AT | |
|
|
| |
|
| #HECK IF ,0 GAS TANK IS EMPTY | |
| .O GAS FLOW | ! )F EMPTY REPLACE | |
| " )F ,0 GAS TANK IS NOT EMPTY REFER TO h3UDDEN DROP IN GAS FLOW OR REDUCED | ||
|
| ||
|
| FLAME HEIGHTv | |
| ,0 GAS TANK IS LOW OR EMPTY | 2EPLACE ,0 GAS TANK | |
| Burner will not light with match | ,0 GAS LEAK | &OLLOW h#HECKING FOR ,EAKSv INSTRUCTIONS IN THE OWNERS MANUAL | |
| Coupling nut and regulator not fully connected | Turning the coupling nut about | |
| SOLID STOP 4IGHTEN BY HAND ONLYDO NOT USE TOOLS | ||
|
| ||
| /BSTRUCTION OF GAS FLOW | #LEAR BURNER TUBES PER CLEANING INSTRUCTION ON WWWBLUERHINOCOM | |
| 3PIDER WEBS OR INSECT NEST IN VENTURI | #LEAN VENTURI AND BURNER TUBE PER CLEANING INSTRUCTION ON WWWBLUERHINOCOM | |
| Burner ports clogged or blocked | #LEAN BURNER PORTS PER CLEANING INSTRUCTION ON WWWBLUERHINOCOM | |
| /UT OF GAS | 2EPLACE ,0 GAS TANK | |
|
| 4URN REGULATORCONTROL KNOB TO h,/#+/&&v | |
|
| 7AIT SECONDS AND LIGHT GRILL | |
|
| )F FLAMES ARE STILL TOO LOW RESET THE EXCESSIVE FLOW SAFETY DEVICE | |
Sudden drop in gas flow or reduced flame height |
| A 4URN REGULATORCONTROL KNOB h,/#+/&&v | |
%XCESS FLOW VALVE TRIPPED SAFETY DEVICE MAY HAVE BEEN | B 2EMOVE ,0 GAS TANK | ||
| ACTIVATED | C 7AIT MINUTE | |
|
| D !TTACH ,0 GAS TANK | |
|
| E 0ERFORM A LEAK CHECK PER h#HECKING FOR ,EAKSv INSTRUCTIONS IN THE OWNERS | |
|
| manual | |
|
| F ,IGHT GRILL PER h,IGHTING )NSTRUCTIONSv INSTRUCTIONS IN THE OWNERS MANUAL | |
Irregular flame pattern, flame does not run the | Burner ports are clogged or blocked | #LEAN BURNER PORTS PER CLEANING INSTRUCTION ON WWWBLUERHINOCOM | |
| full length of burner |
| ||
|
| ||
| .EW BURNER MAY HAVE RESIDUAL MANUFACTURING OILS | "URN GRILL FOR MINUTES ON h()'(v WITH THE LID CLOSED | |
|
|
| |
| Flame is yellow or orange | 3PIDER WEBS OR INSECT NEST IN VENTURI | #LEAN VENTURI PER CLEANING INSTRUCTION ON WWWBLUERHINOCOM | |
|
| ||
&OOD RESIDUE GREASE ETC | #LEAN BURNER PER CLEANING INSTRUCTION ON WWWBLUERHINOCOM | ||
| |||
|
|
| |
| 0OOR ALIGNMENT OF VALVE TO BURNER VENTURI | !SSURE BURNER VENTURI IS PROPERLY ENGAGED WITH VALVE | |
|
|
| |
| (IGH OR GUSTING WINDS | $O NOT USE GRILL IN HIGH WINDS | |
| Flame blow out | ,OW ON ,0 GAS | 2EPLACE ,0 GAS TANK | |
|
| ||
%XCESS FLOW VALVE TRIPPED SAFETY DEVICE MAY HAVE BEEN | 2EFER TO h3UDDEN DROP IN GAS FLOW OR REDUCED FLAME HEIGHTv | ||
| |||
| ACTIVATED |
| |
| Grease buildup | 2EMOVE AND CLEAN ALL GRILL PARTS PER h#LEANING AND #AREv INSTRUCTIONS IN THE | |
| OWNERS MANUAL | ||
| |||
|
| ||
%XCESS FAT IN MEAT | Trim fat from meat before grilling | ||
| |||
|
|
| |
| %XCESSIVE COOKING TEMPERATURE | !DJUST LOWER COOKING TEMPERATURE | |
|
| 4URN CONTROL KNOB TO h,/#+/&&v | |
| Persistent grease fire | Grease trapped by food buildup around burner system | ,EAVE LID IN CLOSED POSITION AND LET FIRE BURN OUT | |
!FTER GRILL COOLS REMOVE AND CLEAN ALL PARTS PER h#LEANING AND #AREv | |||
|
| ||
|
| INSTRUCTIONS IN THE OWNERS MANUAL | |
| Flashback (fire in burner tube(s)) | Burner and/or burner tubes are blocked | #LEAN BURNER ANDOR BURNER TUBE PER CLEANING INSTRUCTION ON WWWBLUERHINO | |
com | |||
|
| ||
| The lid is stainless steel, not painted | Baked on grease buildup has turned to carbon and is flaking off, clean | |
| THOROUGHLY PER h#LEANING AND #AREv INSTRUCTIONS IN THE OWNERS MANUAL | ||
|
| ||
|
|
| |
| Inside of lid is peeling (like paint peeling) |
| This can be from baked on grease buildup, that has turned into carbon and is | |
| FLAKING OFF | ||
| The lid is coated/painted | #LEAN THOROUGHLY PER h#LEANING AND #AREv INSTRUCTIONS IN THE OWNERS MANUAL | |
|
| After cleaning, if you can see steel, please call out Customer Care at | |
|
| ||
|
|
|