Leak Testing Valves, Hose and Regulator | Char-Broil 463270309

Hold coupling nut and regulator

as shown for proper connection

to LP cylinder valve.

6.Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in some resistance. An additional one-half to three-quarters turn is required to complete the connection. Tighten by hand only – do not use tools.

NOTE:

If you cannot complete the connection, disconnect regulator and repeat steps 5 and 6. If you are still unable to complete the

connection, do not use this regulator!

DANGER

•Do not insert any tool or foreign object into the valve outlet or safety relief valve. You may damage the valve and cause a leak. Leaking propane may result in explosion, fire, severe personal injury, or death.

WARNING

•Outdoor gas appliance is not intended to be installed in or on a boat.

•Outdoor gas appliance is not intended to be installed in or on an RV.

•Never attempt to attach this grill to the self-contained LP gas system of a camper trailer or motor home.

•Do not use grill until leak-tested.

•If a leak is detected at any time, STOP and call the fire department.

•If you cannot stop a gas leak, immediately close LPcylinder valve and call LP gas supplier or your fire department!

Leak Testing Valves, Hose and Regulator

1.Turn all grill control knobs to OFF.

2.Be sure regulator is tightly connected to LP cylinder.

3.Completely open LP cylinder valve by turning hand wheel counterclockwise. If you hear a rushing sound, turn gas off immediately. There is a major leak at the connection. Correct before proceeding.

4.Brush soapy solution onto areas circled below.

NOTE: Sideburner

shelf fascia not

shown for clarity.

5.If “growing” bubbles appear, there is a leak. Close LP cylinder valve immediately and retighten connections. If leaks cannot be stopped do not try to repair. Call for replacement parts.

6.Always close LP cylinder valve after performing leak test by turning hand wheel clockwise.

6

Image 6

Char-Broil 463270309 manual Leak Testing Valves, Hose and Regulator, Connection, do not use this regulator

Contents

Estimated assembly time 30 minutes Date Purchased Table of Contents This Grill is for Outdoor USE only Installation Safety Precautions California Proposition USE and Care LP Liquefied Petroleum GasLP Cylinder Filling UseDo not household cleaning agents. Damage to gas Connecting Regulator to the LP CylinderFor your safety LP Cylinder Exchange Leak Testing Valves, Hose and Regulator Connection, do not use this regulatorTurn all grill control knobs to OFF For Safe Use of Your Grill and to Avoid Serious Injury Main Burner Ignitor Lighting Sideburner Match Lighting General Grill CleaningSideburner Ignitor Lighting Burner Flame Check Turn gas OFF at control knobs and LP cylinder Cleaning the Burner AssemblyStoring Your Grill Burner First Time Use TemperatureGrilling Guide Getting Started Lava Rock / Briquettes Direct Cooking Food SafetyGrilling Guide Grilling Indirect Cooking Usda Recommended Safe Minimum Internal Temperatures Grilling Guide Tips & Tricks Grilling Guide Cleaning Your Grill Limited Warranty All Parts Year from date of purchase Parts List Key Qty Description Parts Diagram Assembly Front Grill head Regulator hose Upper back panel Now you may fully tighten lower screws on upper back panel Holes on fascia to Attach valve bracket Electrode Sideburner grate Sideburner Ignitor Wire Rear Heat shield Nut Cap Cylinder screw at rear of cart Grease tray Troubleshooting Emergencies Possible Cause Prevention/Solution Problem Possible Cause Prevention/Solution Troubleshooting Integrated Electronic Ignition SectionPage Regtemp REV00