Cleveland Range 22CET3A CHAPTER 2 OPERATION

CHAPTER 2 – OPERATION

A. GENERAL OPERATION

1. Main External Power Switch

Usually the steamers main external power switch is left ON. If

the main power switch was left in the OFF position, turn it ON

as follows.

a. Turn the ON/OFF lever/switch to the OFF position.

b. The control settings are not important in this

procedure. The control panel circuits are not powered

while the ON/OFF lever/switch is set to OFF.

c. Refer to the main power switch in Figure 2-1, and turn

on electric power to the steamer.

2. Door Interlock Switch

The steamer compartment of the SteamChef¥ 3 is equipped with an automatic steam cutoff switch, which

turns OFF the production of steam and shuts down the convection fan and condenser whenever the door to

the compartment is opened. NOTE: That even though the continued production of additional heat ends as

soon as the door is opened, it may take up to a minute for residual heat in the system to stop producing

steam in the cooking compartment and for the fan to stop rotating. To avoid possible injury always wait until

this residual steam has cleared and the convection fan has stopped rotating before reaching into the

cooking compartment. Remember the SteamChef¥ 3 is always heating in either the standby heat

mode or steam cooking mode, whenever the main power switch is in the ON position and the

steamer door is closed.

3. KleanShield¥

This unit is equipped with the KleanShield¥ for improved maintenance, cooking and safety performance in

the steam cooking of food. The KleanShield¥ (See Figure 2-2) is located in the bottom of the water

reservoir of Cleveland Range SteamChef¥ Cookers and provides the following benefits to the

owner/operator:

xBy collecting all of the drippings of food being

cooked from entering and contaminating the

reservoir water.

xBy keeping the water cleaner, less maintenance is

needed in the daily operation and cleaning of the

interior of the steamer.

xIt directs the steam being produced around the sides

of the pans to insure more even distribution of the

steam.

xIt prevents the operator from accidentally coming in

contact with the reservoir water during the placing or

removal and food from the cooking compartment.

xIt also prevents spilled food from pans from falling directly into the reservoir and splashing out

scalding water.

xThe KleanShield¥ is removable and dishwasher safe allowing for easy cleaning.

Please read the following Important Use and care Instructions for the KleanShield¥

a. Never operate a SteamChef¥ Steamer without a properly installed KleanShield¥.

b. To install the KleanShield¥, the side pan racks must first be removed from the steamer.

MAIN POWER SWITCH

SteamChef

¥

Figure 2-1 Main Power Switch

Figure 2-2 the KleanShield¥