17 Troubleshooting
Symptom | Problem | Solution |
|
|
|
Burner will not | Fuel bottle empty. | Refill fuel bottle 2/3 full with clean and |
light or flame |
| fresh Coleman® fuel or unleaded fuel. |
self- |
|
|
extinguished. |
|
|
|
|
|
Burner will not | Little or no pressure in fuel | Check connections for leaks and |
light or flame is | bottle. | pump 40 strokes. |
low or flame |
|
|
self- |
|
|
extinguished. |
|
|
|
|
|
Yellow flame. | Excess fuel in burner. | A yellow flame is normal until the |
|
| generator warms up. If yellow flame |
|
| persists, turn off stove, allow flame to |
|
| |
|
| If necessary, invert stove to remove |
|
| excess liquid fuel from the burner. |
|
| Follow lighting instructions. |
|
|
|
Low heat. | Generator tip plugged. | Turn flame adjuster back and forth |
|
| several times to clean generator tip. |
|
| Be sure to use only fresh and clean |
|
| fuel. |
|
|
|
Low heat. | Faulty generator. | Replace with a new generator. This is |
|
| a normal periodic maintenance |
|
| procedure. The generator life is |
|
| dependent on the type of fuel used. |
|
| Generator life is extended by using |
|
| clean Coleman® fuel. |
|
|
|
Persistent small | Faulty generator. | Replace with a new generator. |
yellow flame. |
|
|
|
|
|
Persistent high | Failure in the fuel delivery | May need to replace pump assembly. |
yellow flame. | system. | Please contact Consumer Service |
|
| (see page 18). |
|
|
|
Intermittent short | Failure in the fuel delivery | May need to replace pump assembly. |
blue flame and | system. | Please contact Consumer Service |
rapid loss of |
| (see page 18). |
pressure. |
|
|
|
|
|
Yellow smokey | Spider webs, insects, or | Remove burner to inspect and clean |
flame. | other obstruction in the | the burner and air tube. |
| burner and air tube. |
|
|
|
|
Pump does not | Pump seals are dry or | Squirt a few drops of oil in the OIL |
pressurize the | worn. | HOLE in the pump cap. This will keep |
liquid fuel |
| the pump functioning properly |
canister. |
| (Fig. 41). If this does not correct the |
|
| problem, replace the pump seals or |
|
| purchase a new pump assembly. |
|
|
|
Intermittent | Stove has been operated | Adjust the flame to a higher setting |
yellow flame. | for an extended period of | with the FLAME ADJUSTER. |
| time at a low heat setting. |
|
|
|
|