TROUBLESHOOTING TABLE
WARNING: Always stop unit and disconnect spark plug before perform- ing any of the recommended remedies below other than remedies that re- quire operation of the unit.
TROUBLE | CAUSE |
| |
Engh_e will not | 1. | Engine flooded. | |
start. |
|
|
|
| 2. | Fuel | tank empty. |
| 3. | Spark | plug not firing. |
| 4. | Fuel | not reaching |
|
| carburetor. | |
REMEDY
1.See "Starting a Flooded Engine" in Operation section.
2.Fill tank with correct fuel mixture.
3.install new spark plug.
4.Check for dirty fuel filter; replace. Check for kinked or spilt fuel Hne; repair or replace.
| 5. Compression | low. |
Engine will not | 1. Fuel not reaching | |
idle properly. | carburetor. |
|
5. Contact Sears Service (see back cover).
1.Check for dirty fuel filter; replace. Check for kinked or sp_it fuel _ine; repair or replace.
|
|
| 2. | Carburetor | requires | 2. | Contact | Sears | Service | (see | back | cover). | |||||
|
|
|
| adjustment. |
|
|
|
|
|
|
|
|
|
|
| ||
|
|
| 3. | Crankshaft | seals worn. | 3. | Contact | Sears | Service | (see | back | cover). | |||||
|
|
| 4. | Compression | low. | 4. | Contact | Sears | Service | (see | back | cover). | |||||
Engine | will | not | 1. | Air filter | dirty. | 1. | Clean | or |
| replace | air | filter. |
|
| |||
accelerate, |
| 2. | Fuel | not | reaching | 2. | Check | for | dirty fueI | filter; | replace. |
| |||||
lacks | power, or |
| carburetor. |
|
| Check | for | kinked or split | fuel | line; |
| ||||||
|
|
|
|
|
| repair | or | replace. |
|
|
|
| |||||
dies under | a |
|
|
|
|
|
|
|
|
|
| ||||||
load. |
|
| 3. | Spark | plug | fouled. | 3. | Clean | or |
| replace | spark | plug |
|
| ||
|
|
|
|
|
|
|
|
| and |
|
|
|
|
| |||
|
|
| 4. | Carburetor | requires | 4. | Contact Sears Service (see back cover). | ||||||||||
|
|
|
| adjustment. |
|
|
|
|
|
|
|
|
|
|
| ||
5. | Carbon | build | up. |
6. | Compression | low. | |
1. | Choke | partially on. | |
Engine smokes | Fuel mixture | incorrect. | |
2. | |||
excessively. |
|
|
|
5.Contact Sears Service (see back cover).
6.Contact Sears Service (see back cover).
1.Adjust choke.
2.Empty fuel tank and refill with correct fuel mixture.
3. | Air filter dirty. | 3. | Clean | or replace air filter. | |||
4. | Carburetor | requires | 4. | Contact | Sears Service | (see back cover). | |
| adjustment. |
|
|
|
|
| |
1. | Fuel mixture | incorrect. | 1. | See "Fueling Engine" | in Operation | ||
Engine runs hot. |
|
|
| ||||
|
|
|
|
| section. |
|
|
2. | Spark | plug | incorrect. | 2. | Replace with correct spark plug. | ||
|
|
|
| ||||
3. | Carburetor | requires | 3. | Contact Sears Service (see back cover). | |||
| adjustment. |
|
|
|
|
| |
4. | Carbon | build up. | 4. | Contact Sears Service (see back cover). | |||
