immediately prepare your tractor for stor- age at the end of the season or if the trac- tor will not be used for 30 days or more.
_CAUTION- Never store the tractor with gasoline in the tank inside a building where fumes may reach an open flame or spark. Allow the engine to cool before storing in any enclosure.
TRACTOR
Remove mower from tractor for winter storage. This will allow you to clean it thor- oughly. Remove atl dirt, grease, leaves, etco Store in a clean, dry area_
°Clean entire tractor (See "CLEANING" in the Maintenance section of this man-
,ual).
o Inspect and replace belts, if necessary (See belt replacement instructions in the Service and Adjustments section of this
manual).
o Lubricate as shown in the Maintenance section of this manual.
o Be sure that alf nuts, bolts and screws are securely fastened. Inspect moving parts for damage, breakage and wear. Replace if necessary°
o Touch up all rusted or chipped paint sur-
faces; sand lightly before painting.
BATTERY
° Fully charge the battery for storage.
o After a period of time in storage, battery may require recharging_
o To help prevent corrosion and power leakage during long periods of storage, battery cables should be disconnected
and battery cleaned thoroughly (see
"TO CLEAN BATTERY AND TERMI_ NALS" in the Maintenance section of this manual).
o After cleaning, leave cables disconnect- ed and place cables where they cannot come in contact with battery terminals.
•Be sure battery drain tube is securely attatchedo
o If battery is removed from tractor for storage, do not store battery directly on concrete or damp surfaces.
ENGINE
FUEL SYSTEM
IMPORTANT: It is important to prevent gum deposits from forming in essential fuel system parts such as carburetor, fuel
filter, fuel hose, or tank during storage°
Also, experience indicates that alcohol blended fuels (called gas0hel or using
ethanol or methanol) can attract moisture which leads to separation and formation of acids during storage. Acidic gas can dam, age the fuel system of an engine while in
storage. !
•Drain the fuel tank.
°Start the engine and let it run until the fuel lines and carburetor are empty.
°Never use engine or carburetor cleaner products in the fuel tank or permanent
damage may occur.
o Use fresh fuel next season.
NOTE: Fuel stabilizer is an acceptable alternative in minimizing the formation of fuel gum deposits during storage. Add sta- bilizer to gasoline in fuel tank or storage container. Always follow the mix ratio
found on stabilizer container° RU[I engine at least 10 minutes after adding stabilizer
to allow the stabilizer to reach the carbure- tor. Do not drain the gas tank and carbure- tor if using fuel stabilizer.
ENGINE OIL
Drain oil (with engine warm) and replace with clean engine oil. (See "ENGINE" in the Maintenance section of this manual).
CYLINDERS
•Remove spark plug(s).
°Pour one our_ce of oil through spark plug hole(s) into cylinder(s).
°Turn ignition key to "START" position for a few seconds to distribute oil.
o Replace with_new spark plug(s).
OTHER
•Do not store gasoline from one season to another.
o Replace your gasoline can if it starts to rust. Rust and/or dirt in your gasoline will cause problems.
°If possible, s_ore your tractor indoors and cover it tp give protection,f,rom dust
and dirt._
o Cover your tractor with a suitable pro- tective cover that does not retain mois- turer Do not use plastic. Plastic cannot breathe, which allows condensation to form and cause your tractor to rust.
IMPORTANT: Never cover tractor while engine and exhaust areas are still warm°
27
