TROUBLESHOOTING |
| CHART |
|
|
|
| ||
PROBLEM |
| CAUSE |
|
|
|
|
|
|
Mower blades will | 1. | Obstruction | in clutch | |||||
not rotate |
| mechanism. |
|
|
|
| ||
| 2. | Worn/damaged |
| mower | ||||
|
| drive | belt. |
|
|
|
| |
| 3. | Frozen | idler | pulley. | ||||
| 4. | Frozen | blade | mandrel. | ||||
Poor grass | 1. | Engine | speed | too | slow. | |||
discharge |
|
|
|
|
|
|
|
|
| 2. | Travel | speed |
| too | fast. | ||
| 3. | Wet grass. |
|
|
|
| ||
| 4. | Mower |
| deck | not | level. | ||
| 5. | Low/uneven | tire | air | ||||
|
| pressure. |
|
|
|
| ||
| 6. | Worn, | bent | or | loose blade. | |||
| 7. | Buildup | of grass, | leaves | ||||
|
| and trash under mower. | ||||||
| 8. Mower drive belt worn. | |||||||
| 9. | Blades | improperly | installed. | ||||
| 10. Improper | blades | used. | |||||
11 .Clogged mower deck vent holes from buildup of grass, leaves, and trash around mandrels.
CORRECTION
1.Remove obstruction.
2.Replace mower drive belt.
3.Replace idler pulley.
4.Replace blade mandrel.
1.Place throttle control in
"FAST' position.
2.Shift to slower speed.
3.Allow grass to dry before mowing.
4.Level mower deck.
5.Check tires for proper air pressure.
6.Replace/sharpen blade. Tighten blade bolt.
7.Clean underside of mower housing.
8.Replace mower drive belt.
9.Reinstall blades sharp edge down.
10.Replace with blades listed in this manual.
11.Clean around mandrels to open vent holes.
Headlight(s) not | 1. | Switch | is "OFF". |
|
| 1. | Turn switch "ON". |
| |||||||||
working | 2. | Bulb(s) | or | lamp(s) | burned | 2. | Replace bulb(s) or lamp(s). | ||||||||||
[if so equipped) |
| out. |
|
|
|
|
|
|
|
|
|
|
|
|
| ||
|
| 3. | Faulty | light | switch. |
| 3. | Check/replace |
| light switch. | |||||||
|
| 4. | Loose | or | damaged | wiring. | 4. | Check wiring and connec- | |||||||||
|
|
|
|
|
|
|
|
|
|
|
| tions. |
|
|
|
|
|
|
| 5. | Blown | fuse. |
|
|
| 5. | Replace | fuse. |
|
| |||||
Battery | will not | 1. | Bad | battery | cell(s). |
| !. | Replace | battery. |
|
| ||||||
charge |
| 2. | Poor | cable | connections. | 2. | Check/clean | all | connec- | ||||||||
|
|
|
|
|
|
|
|
|
|
|
| tions. |
|
|
|
|
|
|
| 3. | Faulty | regulator |
|
| 3. | Replace | regulator. |
| |||||||
|
|
| (if | so |
| equipped). |
|
|
|
|
|
|
|
|
| ||
|
| 4. | Faulty | alternator. |
| 4. | Replace | alternator. |
| ||||||||
IEngine | "backfires" | . | Engine | throttle | control not | . Move | throttle | control | to | ||||||||
when turning |
| set | at "SLOW" | position |
| "SLOW" | position | and | allow | ||||||||
engine | "OFF" |
| for | 30 | seconds | before |
| to idle | for 30 | seconds | before | ||||||
|
|
| stopping | engine. |
|
| stopping | engine. |
| ||||||||
3O
