HIGH PRESSURE PORTABLE FORCED AIR HEATER 350,000 AND 600,000 BTU/HR
TROUBLESHOOTING
Continued
OBSERVED PROBLEM | POSSIBLE CAUSE | REMEDY | ||||
Heater will not ignite, but motor runs for a | 1. | A) Fuel tank empty | 1. | A) Add fuel to tank. | ||
short period of time |
| B) Water in fuel |
| B) Check fuel tank for bubbles of water | ||
|
| C) Wrong fuel |
| in bottom. If found, remove fuel (see | ||
|
|
|
|
| Storing, Transporting, or Shipping, | |
|
|
|
|
| page 5). Clean tank and fuel filters | |
|
|
|
|
| (see Fuel Filters, page 12). Fill with | |
|
|
|
|
| clean fuel. | |
|
|
|
|
| C) Remove wrong fuel (see Storing, | |
|
|
|
|
| Transporting, or Shipping, page 5). | |
|
|
|
|
| Clean tank and fuel filters (see Fuel | |
|
|
|
|
| Filters, page 12). Fill with correct fuel | |
| 2. | Dirt in nozzle | 2. | Replace nozzle (see Nozzle, page 10) | ||
| 3. | Very low temperature may cause fuel to | 3. | Move heater to warmer place until fuel | ||
|
| thicken and not flow |
| flows freely | ||
| 4. | Dirty fuel filters | 4. | Clean fuel filters (see Fuel Filters, page 12) | ||
| 5. | Wrong pump pressure | 5. | Adjust pump pressure (see Pump Pres- | ||
|
|
|
|
| sure Adjustment, page 11) | |
| 6. | Spark plug wire disconnected from plug | 6. | Connect spark plug wire to spark plug | ||
| 7. | Spark plug problems due to: | 7. | A) Adjust electrode gap to .075" (see | ||
|
| A) Wrong gap |
| Spark Plug, page 10) | ||
|
| B) Plug wet with fuel |
| B) Clean fuel from spark plug with | ||
|
| C) Carbon deposits on plug |
| clean, soft cloth | ||
|
| D) Damaged plug |
| C) Replace plug if heavily coated with | ||
|
|
|
|
| carbon (see Spark Plug, page 10) | |
|
|
|
|
| D) Inspect plug for worn or eroded elec | |
|
|
|
|
| trodes. If found, replace plug (see | |
|
|
|
|
| Spark Plug, page 10) | |
| 8. | Solenoid valve not opening | 8. | Check electrical connections and volt- | ||
|
|
|
|
| age to solenoid. If good, replace sole- | |
|
|
|
|
| noid valve | |
|
|
|
|
| ||
|
|
| WARNING: High Voltage! |
| ||
|
|
|
|
|
|
|
| 9. | Damaged electronic ignitor | 9. | Replace electronic ignitor |
www.desatech.com
8 | 099507 |