16
TROUBLESHOOTING
TROUBLESHOOTING
Continued
WARNING: If you smell gas
•Shut off gas supply.
•Do not try to light any appliance.
•Do not touch any electrical switch; do not use any phone in your building.
•Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.
•If you cannot reach your gas supplier, call the fire department.
IMPORTANT: Operating heater where impurities in air exist may create odors. Cleaning supplies, paint, paint remover, cigarette smoke, cements and glues, new carpet or textiles, etc., create fumes. These fumes may mix with combustion air and create odors. These odors will disappear over time.
OBSERVED PROBLEM | POSSIBLE CAUSE | REMEDY | ||
Heater produces a clicking/ticking noise | 1. | Metal expanding while heating or con- | 1. | This is common with most heaters. If |
just after burner is lit or shut off |
| tracting while cooling |
| noise is excessive, contact qualified ser- |
|
|
|
| vice person |
|
|
|
|
|
Heater produces unwanted odors | 1. | Heater burning vapors from paint, hair | 1. | Open window and ventilate room. Stop |
|
| spray, glues, cleaners, chemicals, new |
| using odor causing products while heater |
|
| carpet, etc. (See IMPORTANT state- |
| is running |
|
| ment above) |
|
|
| 2. | Gas leak. SeeWarning statement at | 2. | Locate and correct all leaks (see Check- |
|
| top of page |
| ing Gas Connections, page 9) |
|
|
|
|
|
Heater shuts off in use (ODS operates) | 1. | Not enough fresh air is available | 1. | Open window and/or door for ventilation |
| 2. | Low line pressure | 2. | Contact local natural or propane/LP gas |
| 3. | ODS/pilot is partially clogged |
| company |
| 3. | Clean ODS/pilot (see Cleaning and | ||
|
|
|
| Maintenance, page 13) |
|
|
|
|
|
Gas odor even when control knob is in OFF | 1. | Gas leak. SeeWarning statement at | 1. | Locate and correct all leaks (see Check- |
position |
| top of page |
| ing Gas Connections, page 9) |
| 2. | Control valve defective | 2. | Replace control valve |
|
|
|
|
|
Gas odor during combustion | 1. | Foreign matter between control valve | 1. | Take apart gas tubing and remove for- |
|
| and burner |
| eign matter |
| 2. | Gas leak. SeeWarning statement at | 2. | Locate and correct all leaks (see Check- |
|
| top of page |
| ing Gas Connections, page 9) |
For
.
.com
