Servicing
Continued
Replacing Screens
1.Open upper control panel door. Turn power switch off.
2.Open
3.Remove 2 screws securing screen rods (see Figure 14).
4.Tilt rod down and remove from bracket.
5.Remove old screen from rod and discard. Install new screen onto rod.
6.Reinstall rod into bracket and replace screws.
7.Close doors.
Mounting
Holes 
Screen 
Rod
Retaining
Screw
Figure 14 - Removing Screen/Rod Assembly
Replacing Ember Strip
1.Follow steps 1 and 4 under Replacing Log, page 9.
2.Locate ember LED strip (see Figure 13, page 9). Disconnect wire (right side).
3.Remove ember LED strip by squeezing top of standoffs and discard.
4.Being careful not to break LED strip, press new ember LED strip onto standoffs.
5.Reconnect wire to LED strip.
6.Follow steps 5 through 7 under Replacing Log, page 9.
Service Preparation
Perform steps 1 through 4 below, then locate part that needs replacing in the instructions that follow.
1.Open control panel door. Turn off power to unit (circuit breaker).
2.Open
3.Remove screws securing each side of log to brackets (see Figure 13, page 9).
4.Carefully remove log.
5.Remove screws from back corners and front of top panel (see Figure 15). Remove top panel and set aside.
Note: For LED drum and motor, only remove back screws. Top panel does not have to be completely removed. Care- fully push top panel up to remove screen glass.
6.Using gloves, gently remove glass panel by sliding it toward you. There is a rubber bumper on each corner of glass. Set aside in a safe location.
7.Follow instructions on pages 11 thru 13 to replace part.
8.Using gloves, install glass by gently slid- ing, smooth side toward fireplace front, into brackets on either side that hold glass in place.
9.Reinstall top panel. Pull top panel down so that screen glass seats into glass retainer.
10.Reinstall screws from step 5.
11.Reinstall log.
12.Reinstall screws into brackets to secure log.
13.Close screens and doors.
14.Turn on power to unit (circuit breaker).
Control
Panel
Door
Top Panel
Screen Glass
Figure 15 - Removing Screen Glass (all
parts not shown for clarity)
10 | www.desatech.com |