Electrical Data | Generac Power Systems 004992-0, 004992-1 specs

Section 6 - Electrical Data

Guardian 40kW Liquid-cooled Generators

Electrical Schematic — Engine — Drawing No. 0E8116-A

26 Generac® Power Systems, Inc.

Page 28

Image 28

Generac Power Systems 004992-1, 004992-0, 004992-0, 004992-1, 37kW NG, 40kW LP owner manual Electrical Data

Contents

Liquid-cooled, Prepackaged Standby Generators ‹ Operation and Maintenance ‹ HOW to Obtain ServiceIntroduction ‹ Read this Manual Thoroughly Table of Contents General Hazards Electrical Hazards Transfer Switch GeneratorAutomatic System Operation Generator AC Connection Systems ‹ 1.7.1 LOW OIL Pressure Switch ‹ 1.7.2 High Coolant Temperature Switch‹ 1.7.3 LOW Coolant Level Switch Generator Fuel System Unpacking Lifting the Generator Specifications Reconfiguring the Fuel System‹ 1.10.1 Generator Specifications ‹ 1.10.2 Engine Specifications Torque Specifications Before InstallationEngine OIL Recommendations Coolant Recommendations Generator Location Generator Mounting SupportBasic Standby Electric System ‹ 2.1.1 Nfpa Standards Total Circuit Isolation Method Emergency Circuit Isolation MethodGenerator AC Neutral Connections Transfer Switch Signal Connections Battery Installation‹ 2.9.1 PRE-PACKAGED ATS ‹ 2.9.2 GTS-TYPE ATS Preparation Before START-UP Using AN Engineered GTS Transfer Switch ‹ 3.2.1 AUTO/OFF/MANUAL Switch‹ 3.2.2 Fault Indicator Leds Control Console Components Engine Governor Adjustments ‹ 3.2.5 SET Exercise Time SwitchManual Transfer START-UP ‹ 3.2.6 System Ready LED Automatic Operation Weekly Exercise Cycle Checking Fluid Levels Overload Protection for Engine DC Electrical SystemCooling System ‹ 4.5.2 Check Battery ‹ 4.5.8 Check FAN Belt‹ 4.5.9 Inspect Engine Governor ‹ 4.5.1 Check Engine OIL Level Miscellaneous Maintenance ‹ 4.6.1 Cleaning the Generator‹ 4.5.11 Changing the Engine AIR Cleaner ‹ 4.5.13 Coolant Change ‹ 4.6.3 Battery Maintenance ‹ 4.6.4 Battery Replacement Scheduled Maintenance Service Maintenance Interval Information Level Maintenance Level Troubleshooting Points Problem Cause Correction Electrical Data Electrical Data Electrical Data Electrical Data Carrier Rear Bearing Assy Wire Hold Down BatteryBoot Battery Cable Battery Post Covwer Black See Latch Detail Assy GRD Wire 99HSB Assembly BASE-DOOR Ground WireIntake Duct HSB Duct Discharge RH Front Generac Power Systems, Inc Assy 2A 12V UL Battery Control BOX HSBCover Front Panel HSB Cover TOP Panel HSB Generac Power Systems, Inc COVER, Flywheel Access ASSEMBLY, ResistorFlexplate 3.9L HSB MACHINING, 3.9L Engine Pump Tank Coolant Recovery Radiator Copper BrassVENTURI,3.9L Cryslr HSB 22FAN Radiator Support L/H Side To Engine Base AIR Cleaner Plate Hold Down AIR CleanerPlate AIR Cleaner TOP Flange Fuel Inlet Leads Rotor 390 30KW 1P Direct HSB Rotor 390 40KW 1P Direct HSBSTR-390--40AD HSB 433MM LONG3.9L Chrysler Rear Bearing Carrier 390/DRCT NUT TOP Lock FL M12-1.75 OUTWYE, Pipe 3.9L Chrysler Exhaust Flange 2 Pipe Installation Diagram Guardian 40kW Liquid-cooled Generators Guardian 40kW Liquid-cooled Generators This Warranty Shall not Apply to the Following

Generac Power Systems 004992-0, 004992-1, 004992-1, 004992-0 owner manual Electrical Data

Models: 004992-0, 004992-1 004992-1, 004992-0 004992-0, 004992-1, 37kW NG, 40kW LP

Section 6 - Electrical Data