Installation
1.
2.
3.
4.
IMPORTANTTO ALLOW 6” CLEAR SPACE FOR ACCESS TO CONTROL BOX.
Urn should be level, both front to back and left to right.
CONNECT WATERLINE. 3/8” NPT water inlet located at left end and provide shutoff
valve and union in supply line near urn. 140OF. hot water must be used, 30PSI mini-
mum - 70PSI maximum. We strongly recommend the use of copper or aluminum tub-
ing to provide flexibility and avoid strain on the urn. 3/8” O.D. minimum tubing is rec-
ommended.
Model No. 87710
Actual Coffee Capacity Each Liner 10 Gal.
Water Compartment Capacity 24 Gal.
Brew Capacity, Gals. per Hour 80
Electric Supply Voltage 240V/208V
1 Phase Heater Size 15KW / 15KW
1 Phase Amperes 63 / 72
3 Phase Heater Size 15KW / 15KW
3 Phase Amperes 36 / 42
CONNECT URN TO ELECTRIC POWER. Check to be sure that the nameplate mark-
ing of voltage, phase and the number of wires matches supply lines. Remove cover on
control housing. The terminal block for the line connections is located in the housing
on the left end. See drawing, as required. It is recommended that a fused disconnect
switch be installed near urn. The urn body must be grounded either through metallic
conduit or else by means of ground wire. An experienced electrician should be respon-
sible for the installation of the urn, and its associated supply line. NOTE: Neutral wire
required on all single phase and on 208 volt 3 phase power supplies to operate 120 volt
AC control circuit.
On single phase, 2 wire service (no neutral) or 3 phase 3 wire service (no neutral) 120
volt AC power to operate control circuit must be supplied as circuit. Do not replace
cover until completing installation start-up.
FILL WATER COMPARTMENT. Turn on water supply and electric service to urn.
Water compartment should fill to stop-full level in approximately 10 minutes.
Turn thermostat knob to BREW position. Pilot light over knob should light showing
heater power on. Water compartment should reach operating temperature approxi-
mately 45 minutes later. When the pointer on thermometer approaches the “W” in the
blue BREW zone, urn is ready for automatic operation.
American Metal Ware 87710E Coffee Urn Page 5