Section 4 — Troubleshooting

Portable Generator System

4.1 TROUBLESHOOTING GUIDE

PROBLEM

CAUSE

CORRECTION

Engine is running, but no AC

1.

 

Circuit breaker is open.

1.

 

Reset circuit breaker.

output is available.

2.

 

Poor connection or defective cord set.

2.

 

Check and repair.

 

3.

 

Connected device is bad.

3.

 

Connect another device that is in good condition.

 

4.

 

Fault in generator.

4.

 

Contact Authorized Service Facility.

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Engine runs good but

1.

 

Short circuit in a connected load.

1.

 

Disconnect shorted electrical load.

bogs down when loads are

2.

 

Generator is overloaded.

2.

See “Don’t Overload the Generator” .

connected.

3.

 

Engine speed is too slow.

3.

 

Contact Authorized Service Facility.

 

4.

 

Shorted generator circuit.

4.

 

Contact Authorized Service Facility.

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Engine will not crank.

1.

 

10 amp fuse at rear of generator control panel

1.

 

Replace fuse with only an identical 10-amp

 

 

 

has melted open.

 

 

replacement fuse.

 

2.

 

Battery weak or dead.

2.

 

Recharge or replace battery.

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Engine will not start; or

1.

 

Dirty air cleaner.

1.

 

Clean or replace air cleaner.

starts and runs rough.

2.

 

Out of gasoline.

2.

 

Fill fuel tank.

 

3.

 

Stale gasoline.

3.

 

Drain fuel tank and fill with fresh fuel.

 

4.

 

Spark plug wire not connected to spark plug.

4.

 

Connect wire to spark plug.

 

5.

 

Bad spark plug.

5.

 

Replace spark plug.

 

6.

Water in gasoline.

6.

 

Drain fuel tank; fill with fresh fuel.

 

7.

 

Overchoking.

7.

 

Put choke knob to No Choke position.

 

8.

 

Low oil level.

8.

 

Fill crankcase to proper level.

 

9.

 

Excessive rich fuel mixture.

9.

 

Contact Authorized Service Facility.

 

10.

Intake valve stuck open or closed.

10.

Contact Authorized Service Facility.

 

11.

Engine has lost compression.

11.

Contact Authorized Service Facility.

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Engine shuts down during

1.

 

Out of gasoline.

1.

 

Fill fuel tank.

operation.

2.

 

Low oil level.

2.

 

Fill crankcase to proper level.

 

3.

 

Fault in engine.

3.

 

Contact Authorized Service Facility.

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Engine lacks power.

1.

 

Load is too high.

1.

 

See “Don’t Overload the Generator”.

 

2.

 

Dirty air filter.

2.

 

Replace air filter.

 

3.

 

Engine needs to be serviced.

3.

 

Contact Authorized Service Facility.

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Engine “hunts” or falters.

1.

 

Choke is opened too soon.

1.

 

Move choke to halfway position until engine runs

 

2.

 

Carburetor is running too rich or too lean.

 

 

smoothly.

 

 

 

 

2.

 

Contact Authorized Service Facility.

 

 

 

 

 

 

 

 

 

 

 

 

 

 

No Battery Charge DC

1.

 

Battery posts are corroded.

1.

 

Clean battery posts.

output.

2.

 

Battery cable is bad.

2.

 

Replace cable.

 

3.

 

Battery is defective.

3.

 

Check battery condition; replace if defective.

 

4.

 

Receptacle is bad.

4.

 

Contact Authorized Service Facility.

 

 

 

 

 

 

 

18

Page 20
Image 20
Guardian Technologies 004583-0 owner manual Troubleshooting Guide

004583-0 specifications

Guardian Technologies 004583-0 is a noteworthy air purifying solution designed for effective indoor air quality management. This device is specifically designed to eliminate harmful particles and improve the overall environment in homes, offices, and other enclosed spaces. The primary objective of this air purifier is to provide users with cleaner air free from allergens, pollutants, and odors.

One of the standout features of the Guardian Technologies 004583-0 is its advanced True HEPA filtration system. This technology is capable of capturing 99.97% of dust, pollen, smoke, mold spores, and pet dander as small as 0.3 microns. This level of filtration is especially beneficial for allergy sufferers and individuals with respiratory issues. The inclusion of a pre-filter further helps to extend the life of the HEPA filter by trapping larger particles before they reach the HEPA layer.

Additionally, the Guardian Technologies 004583-0 incorporates UV-C light technology, which effectively kills airborne bacteria and viruses. This feature adds an extra layer of protection, ensuring that the air being circulated is not only free from particulates but also from harmful microorganisms. The synergistic effect of the HEPA filter and UV-C light makes this air purifier a robust solution for maintaining a healthy indoor atmosphere.

The design of the Guardian Technologies 004583-0 is another notable characteristic. It features a sleek and modern aesthetic, making it a fitting addition to any room's decor. Its compact size ensures that it can be placed in various locations without taking up excessive space. The device operates quietly, which means it can function efficiently in bedrooms, living rooms, or offices without causing distractions.

Furthermore, ease of use is a key element in the design of the Guardian Technologies 004583-0. It comes equipped with user-friendly controls that allow for straightforward operation and maintenance. Users can easily adjust fan speeds, engage the UV-C light, and monitor filter replacement indicators.

Overall, the Guardian Technologies 004583-0 stands out in the air purifier market due to its combination of efficient filtration, advanced technology, and user-friendly design. It presents an ideal solution for anyone seeking to improve their indoor air quality and create a healthier living or working environment.